lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars

Post New Thread  Reply
Thread Tools Display Modes
Unread 11-25-2010, 12:12 AM   #1
Getting Wild
tazassape's Avatar
Join Date: Nov 2010
Location: Lewisburg, Louisiana
Posts: 142
Default Good 20 min. Then hard to get going WTF

1990 CC DS rides good for maybe 20 minutes, then when go pedal is lifted will take 30-40 seconds to go again. Banging on the pedal seems to make it go but I know sometning is wrong. Always starts problem after being ridden a while. We have cleaned and tightened all connections. Braided wire on the v-glide is pretty kinked. Problem? Braided wire in the v-glide cable or a bad senoniod? All wire and connections were cleaned and sealed. Any help would be greatly appreciated. Thanks

Last edited by tazassape; 11-25-2010 at 12:21 AM.. Reason: clear up
tazassape is offline   Reply With Quote
Alt Today

Golf car forum Sponsored Links

This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
Unread 11-25-2010, 09:02 AM   #2
Gone Wild
OLD MEC's Avatar
Club Car
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: Good 20 min. Then hard to get going WTF

Often the problem in V glide is the "wiper switch spring" or wear in "bronze bushings" that holds wiper assembly against contacts. By moving the pedal up and down you can make contact again. I would do a repair job and replace switch brush assermbly ( this takes care of braided wire ) and spring and check wear on wiper through bushing, and while apart I usually replace the limit micro switch to be sure as they some times stick and wont allow solenoid to operate? Check contacts inside for pitting and burning as poor connections will cause all kinds of weird pedal problems. I clean contacts with very fine emery cloth and a small flat block to make sure contacts are even all the way across face.
OLD MEC is offline   Reply With Quote
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car

Thread Tools
Display Modes

Similar Threads
Thread Forum
Hard Starting EZ-Go Gas EZGO
Replaced OBC, Charger is good, good cables, Specific gravity is off the charts, but.. Electric Club Car
How hard can I run my g16? Gas Yamaha
hard shift? Gas Club Car
Hard to start Gas EZGO

All times are GMT -5. The time now is 08:22 PM.

Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2018, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.