lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 12-08-2010, 08:12 PM   #1
Not Yet Wild
 
Join Date: Dec 2010
Posts: 2
Default replaced wiper on v glide & now it won't move

bought a used 99 48 volt cart & it acted strange when you pushed the go pedal. Pulled the v glide & found the wiper wire was all but broken in 2. also noticed a wire on the resistor side was missing the nut so i installed one. got it back together & now it won't move. i can hear the micro switch when i push on the go pedal with the key off & a solenoid when the key is on. but it won't move forward or reverse????? Thanks, gts
gts440 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 12-09-2010, 11:41 AM   #2
Gone Wild
 
OLD MEC's Avatar
Club Car
 
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: replaced wiper on v glide & now it won't move

I would check your solenoid for internal contact if it clicks each time key is on, F&R in gear and pedal is pushed down. Just because it clicks doesn't mean its making contact inside.
For safety sake jack up rear of cart and support on jack stands under axle near springs on good solid flat surface and then block front wheels so cart cannot move. Put a jumper cable across both large posts on solenoid and turn key on, put F&R in forward, and see if motor runs ( WARNING IF MOTOR TURNS DO NOT ALLOW IT TO RUN OVER A FEW SECONDS AS IT WILL RUIN MOTOR AND ENDANGER YOU FROM FLYING PIECES )
If it runs you know you need to replace the solenoid and also the Doide unit, Resistor unit. NOTE be sure diode is installed correctly with band toward "plus or power" side of small posts on solenoid.
OLD MEC is offline   Reply With Quote
Unread 12-09-2010, 09:23 PM   #3
Not Yet Wild
 
Join Date: Dec 2010
Posts: 2
Default Re: replaced wiper on v glide & now it won't move

Thanks! Remember that loose wire I put the nut on? That was the wire that goes to my wiper. I put it on the wiper stud & all is well! Sometimes I get in a hurry & do stupid things especially when I took it apart a week before
gts440 is offline   Reply With Quote
Unread 12-10-2010, 03:52 PM   #4
Gone Wild
 
OLD MEC's Avatar
Club Car
 
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: replaced wiper on v glide & now it won't move

We all make mistakes and it gets worse the older we get? Glad it was a simple fix.
OLD MEC is offline   Reply With Quote
Unread 12-10-2010, 03:55 PM   #5
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,053
Default Re: replaced wiper on v glide & now it won't move

Quote:
Originally Posted by OLD MEC View Post
We all make mistakes and it gets worse the older we get? Glad it was a simple fix.
I don't know OLDMEC, I made some pretty good mistakes when I was young
scottyb is offline   Reply With Quote
Unread 12-10-2010, 04:06 PM   #6
Gone Wild
 
OLD MEC's Avatar
Club Car
 
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: replaced wiper on v glide & now it won't move

SCOTTYB--Sorry to say but it goes downhill the older you get? The young mistakes we can blame on being young and in love etc?
OLD MEC is offline   Reply With Quote
Unread 12-10-2010, 04:11 PM   #7
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,053
Default Re: replaced wiper on v glide & now it won't move

I dunno the whole fast thing is settling down for me... when I was young it was fast cars, fast women, and fast horses
scottyb is offline   Reply With Quote
Unread 12-10-2010, 04:22 PM   #8
Gone Wild
 
OLD MEC's Avatar
Club Car
 
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: replaced wiper on v glide & now it won't move

SCOTTYB-- Fast cars, faster motor cycles YES, Women NO ( married at 17 ) Married 60 years in November 2010
OLD MEC is offline   Reply With Quote
Unread 12-10-2010, 04:25 PM   #9
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,053
Default Re: replaced wiper on v glide & now it won't move

Congrats... 60 years is an accomplishment she is to be commended for
scottyb is offline   Reply With Quote
Unread 12-11-2010, 09:39 AM   #10
Gone Wild
 
OLD MEC's Avatar
Club Car
 
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: replaced wiper on v glide & now it won't move

Yahh putting up with my bs?
OLD MEC is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Windshield Wiper Electric Club Car
2000 V-Glide wiper play Electric Club Car
4 guage wiper arm wire Electric EZGO
V-Glide doesn't glide - 1992 36v Electric Club Car
Westie Wiper rebuild..... Electric golf carts


All times are GMT -5. The time now is 01:19 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.