cart cutting out

newrider

recently got an 01 series cart was running fine put lift and 22 inch tires now sometimes when you push the gas pedal down quickly it will start jerking and fills like selinoid is clicking yellow bat light comes on also. you can slowly give gas and seems to be fine. any ideas would be great

BGW

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

OLD MEC

Light usually indicates battery, cable, or OBC problems? WONDERING did you disconnect cables from motor while adding lift in rear as it can swing around and hit and damage wiring, motor, solenoid, controller or OBC? I would check all the batterys to confirn that you dont have a weak cell or cells. Then check all your wiring for a loose connection. Then its trial and error finding problem as it may not have anything directly to do with job of lifting cart?
It can be MCOR pedal speed control not making good contact through range of travel?

newrider

i disconnected bat before i put kit on i check bat volts were little low have charging now i not sure what or where the mcro swith is. is it the black box mounted to the frame on passanger side if so any way to clean

GLEEMO

Bump

OLD MEC

The MCOR is located under passenger side floor and is a sealed unit sorry no cleaning can be done to it. Before doing anything else you should test your batterys for weak cell or cells as without proper battery power nothing is going to work right. Then check cables and connection points. There is a vay of testing a MCOR unit if you have a digital volt, amp, ohms meter available and are familiar with its operation?

newrider

let charge allnight checked batts all checked about 90 percent rode for 45 min no problems at all must have been low bats got to get guage anyone know some good one. also anybody know anything about emp 2 speed motors

GLEEMO

Put this thing on the charger and let it run until charger cuts off , wait 8-10 hours and test batteries if they are not close to 100% , its time for new ones.

Go by the chart here http://www.buggiesgonewild.com/elect...-readings.html

OLD MEC

I get mine from local Habor Freight for about $4-$7, if I have problems just get another and throw old one away. ( I get two at a time but still on second one after 4 years BUT NOT highest quality by far, but good enough for a Abama income poor retiree )?

GLEEMO

"Abama" , Gazoontite, U may be coming down with something

OLD MEC

I'm afraid the whole USA is coming down with some thing that needs voted or impeached out right away?