lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 03-02-2011, 08:10 AM   #1
Not Yet Wild
 
Join Date: Feb 2011
Posts: 4
Default Precedent/Replaced Batteries,OBC/Still no go

04 Precedent/ Replaced Batteries and OBC, nothing until I plug charger in to cart and unplug, (Charger not plugged in to wall outlet) then it just buzzes in reverse/ no go
bugwire is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 03-02-2011, 09:24 AM   #2
Gone Wild
 
OLD MEC's Avatar
Club Car
 
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: Precedent/Replaced Batteries,OBC/Still no go

Has anything been done to cart prior to this problem other than what was indicated? Was this the reason for replacing batterys and OBC?
Do you have a digital volt meter available? If so start with basics and test ( total battery pack ) for correct voltage of about 50.96 volts. Just because batterys are new does not mean you have proper voltage for several reasons. Improper wiring, defective battery, the possible improper shut down procedure before installation of batterys?
Please advise if you have meter and know how to use it.
OLD MEC is offline   Reply With Quote
Unread 03-10-2011, 09:26 AM   #3
Not Yet Wild
 
Join Date: Feb 2011
Posts: 4
Default Re: Precedent/Replaced Batteries,OBC/Still no go

Voltage is 51, each battery load tests good, what is the proper way to install batteries? Cart worked well last fall, batteries were not holding charge so I replaced them.
bugwire is offline   Reply With Quote
Unread 03-10-2011, 10:36 AM   #4
Gone Wild
 
OLD MEC's Avatar
Club Car
 
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: Precedent/Replaced Batteries,OBC/Still no go

Proper way to do any work on electric carts wiring and batterys and especially with IQ carts is following
#1 turn key switch to OFF
#2 place tow-run switch in TOW
#3 F&R in NEUTRAL
#4 remove battery pack GROUND CABLE ( cable that goes through OBC ) at battery post wrap cable end with electrical tape to keep from shorting against battery terminals
#5 Tow-Run switch to RUN
#6 Key ON
#7 F&R in REVERSE hold throttle pedal down for 5 minutes ( this discharges and resets OBC and capacitors )
#8 Key OFF
#9 F&R in NEUTRAL
#10 Tow-Run switch to TOW ( at this point I tape switch so cannot be turned on accidentaly )
#11 remove pack POSITIVE CABLE from battery post and wrap tape around cable end
#12 THIS IS MY ADD ON ( cover batterys with blanket, towel or rags "NON CONDUCTIVE MATERIAL" so no accidental shorting to batterys isn't possible
To RECONNECT DO FOLLOWING
A-Key switch OFF
B-Run-Tow in TOW
C-F&R in NEUTRAL
D-Replace Pack POSITIVE CABLE TO battery PLUS post
E-Replace Pack NEGATIVE CABLE to Battery NEGATIVE post
F-Run-Tow to RUN
G-F&R to FORWARD
H-Key Switch ON
Did you replace batterys last fall and fully charge them before using cart? And if so did you leave charger plugged in during winter months? Not the best way to break a new battery pack in but better than none?
OLD MEC is offline   Reply With Quote
Unread 03-10-2011, 06:41 PM   #5
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: Precedent/Replaced Batteries,OBC/Still no go

Status check U still having difficulties ???
GLEEMO is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Precedent 12V Batteries Electric Club Car
2007 CC precedent needs new batteries Electric Club Car
EzGO gone and replaced with Precedent Electric EZGO
Batteries need replaced? Electric EZGO
Batteries for '05 Precedent Electric Club Car


All times are GMT -5. The time now is 11:01 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.