lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 03-19-2011, 09:29 AM   #1
Getting Wild
 
orions empire's Avatar
Club Car
 
Join Date: Aug 2010
Location: PR
Posts: 105
Default '96 48v cc click, wont go!

Hi Guys,

*I have been around a while doing a lot of reading, and learning a lot from other posts. *However, I am no able to find any solution to my current problem.

*I was driving my cart for two hours non stop here at Puerto Rico, it was a hot weather, I would say about 99 degrees out there, the cart was running so far, very good, good speed. *All the sudden it stopped by it self, still have charge on the batteries, but wouldn't move. *I could hear the clicking from the solenoid every time I pressed the pedal with the key switch on, *but no luck.

I have a '96 48v CC, I did the battery readings and they are 55.8v full pack, all wires are clean and good contact. *F/R switch us under the leg at the center of the panel, is not a switch f/r. *I have replaced the solenoid thinking it was a bad solenoid, and still hear the *clicking noise when pressing the pedal, but wont go. *I have tried jumpering the two big poles from the solenoid, and the cart jacked up, but still the wheels wont spin. *

*The only clicking I hear when pressing the pedal is from the solenoid. *What could be causing my cart to not run?

PS: forgiveness for my bad english... *lol
orions empire is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 03-19-2011, 09:35 AM   #2
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,048
Default Re: '96 48v cc click, wont go!

Your English is better than some hillbilly's Well, check all the cable connections with a tug and twist... with a voltmeter check that the F&R switch is putting power out? IF power is getting to the controller. Then you have to suspect the controller or motor?
scottyb is offline   Reply With Quote
Unread 03-19-2011, 10:13 AM   #3
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: '96 48v cc click, wont go!

a few other things, is your charger still working? you can also run a jumper from solenoid small post where yellow wire is bolted over to #6 battery neg. post and see if cart runs..............if so your OBC might have took a dump, what color is controler black or silver?.............................
shadowman is offline   Reply With Quote
Unread 03-19-2011, 10:36 AM   #4
Getting Wild
 
orions empire's Avatar
Club Car
 
Join Date: Aug 2010
Location: PR
Posts: 105
Default Re: '96 48v cc click, wont go!

Controller is gray, also, how do i test my f/r switch?
orions empire is offline   Reply With Quote
Unread 03-20-2011, 01:16 PM   #5
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: '96 48v cc click, wont go!

Do U still get a buzzer sound in reverse ?
GLEEMO is offline   Reply With Quote
Unread 03-20-2011, 02:57 PM   #6
Gone Wild
 
golfcarfixer's Avatar
Club Car
 
Join Date: Sep 2009
Location: DELAWARE
Posts: 2,656
Default Re: '96 48v cc click, wont go!

Also do you have a micro switch under the gas pedal? or does it have the pie shaped wiper switch under the charging receptacle?
golfcarfixer is offline   Reply With Quote
Unread 04-07-2011, 11:40 AM   #7
Getting Wild
 
orions empire's Avatar
Club Car
 
Join Date: Aug 2010
Location: PR
Posts: 105
Default Re: '96 48v cc click, wont go!

GLEEMO: I do get the buzzing when reverse.

GOLFCARFIXER: I have the wiper switch under the drivers right leg F/R wiper.

Any suggestions.???
orions empire is offline   Reply With Quote
Unread 04-07-2011, 11:41 AM   #8
Getting Wild
 
orions empire's Avatar
Club Car
 
Join Date: Aug 2010
Location: PR
Posts: 105
Default Re: '96 48v cc click, wont go!

GLEEMO: I do get the buzzing when reverse.

GOLFCARFIXER: I have the wiper switch under the drivers right leg F/R wiper.

Any suggestions.???
orions empire is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
RXV 2009 click click but won't move Electric EZGO
Click Click - will not move ! Electric EZGO
Solenoid wont "click" Electric EZGO
click click click Electric Club Car
EZGO 2003 solenoid wont click. Electric EZGO


All times are GMT -5. The time now is 04:24 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.