lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 03-25-2011, 06:20 PM   #21
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 1997 Electric DS 48V NO MOVEMENT

that 10 gage black wire comes out of the OBC and bolts to the rear of charger receptical that how it should go..................................


if this is a 97 single soleniod cart try this if your sure soleniod is good..........run a jumper wire from the soleniod small post where yellow wire is bolted over to the #6 battery neg. terminal and see if cart runs if it does OBC is bad.................97 if you still have a red dash battery light chances are its the original OBC and they are famus for crapping out ......cart won,t run or charge unless you bypass low voltage sensor in charger than you can use charger.............but try the jumper see if it works, one last thing those battery voltage #,s you posted are still no good but should be good enough to see if cart will run.
shadowman is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 03-25-2011, 09:22 PM   #22
Not Yet Wild
 
Join Date: Mar 2011
Posts: 21
Default Re: 1997 Electric DS 48V NO MOVEMENT

No the wire that goes thru the computer that links the negative side of the battery pack to the controler as well as the smaller 10 ga wire that connects on the same post on the controler are fine. I am refering to the other 10 ga wire that goes out of the on board colmputer to the charger plug.

* this is in responce to an earlyer post*

Thanks Shadowman! That seems to describe my situation. Im heading out of town tomorrow so ill give this a try tomorrow.
jjcatqfi is offline   Reply With Quote
Unread 03-27-2011, 03:07 PM   #23
Not Yet Wild
 
Join Date: Mar 2011
Posts: 21
Default Re: 1997 Electric DS 48V NO MOVEMENT

Jumper from negative #6 battery causes the solenoid to click when the accelerator peddle is pressed.

no motion in either direction....
jjcatqfi is offline   Reply With Quote
Unread 03-27-2011, 03:36 PM   #24
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 1997 Electric DS 48V NO MOVEMENT

i think you have a bad OBC..........................
shadowman is offline   Reply With Quote
Unread 03-28-2011, 11:49 AM   #25
Not Yet Wild
 
Join Date: Mar 2011
Posts: 21
Default Re: 1997 Electric DS 48V NO MOVEMENT

OUCH, that sounds expensive. What are my options?
jjcatqfi is offline   Reply With Quote
Unread 03-28-2011, 12:06 PM   #26
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 1997 Electric DS 48V NO MOVEMENT

not many...the OBC is only about 130.00 dollars and not difficult to install will take 45 minuts or so.............................
shadowman is offline   Reply With Quote
Unread 03-28-2011, 02:42 PM   #27
Not Yet Wild
 
Join Date: Mar 2011
Posts: 21
Default Re: 1997 Electric DS 48V NO MOVEMENT

Do you have a source for that? My local dealer quoted me $500!
jjcatqfi is offline   Reply With Quote
Unread 03-28-2011, 02:42 PM   #28
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: 1997 Electric DS 48V NO MOVEMENT

U could spend the $50+ dollers and get the 1997 Maint/Service manual it has the procedure for testing the OBC . CC does not share any of the service repair stuff on line .
GLEEMO is offline   Reply With Quote
Unread 03-28-2011, 02:57 PM   #29
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: 1997 Electric DS 48V NO MOVEMENT

$500 that must be a CC dealer installed (with gold screws)
GLEEMO is offline   Reply With Quote
Unread 03-28-2011, 03:23 PM   #30
Not Yet Wild
 
Join Date: Mar 2011
Posts: 21
Default Re: 1997 Electric DS 48V NO MOVEMENT

Club car is.... proud of their products. :)

pulled the obc.... Reads:
ON BOARD COMPUTER
mfd. LESTER ELECTRICAL
PART NO: 16705
USE ONLY WITH CLUB CAR POWER DRIVE BATTERY
CHARGERS ON 48 VDC (24 CELL) BATTERY SYSTEMS
LE9709709399 Ver. 1.33 PATENT PENDING


Interesting side note. It appears that some one has taken a hammer??? and beat the daylights out of the bottom edge of the OBC not just afew hits, but something you would wack at for the better part of 5 or 10 minutes.

What about my controler???? Can i assume its ok? Is there a way to test is directly? Or with out the OBC the controller has no function.


*update* Appearely i screwed up, called club car back with part number 1018006 price goes to $156.99
jjcatqfi is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
1994 Ez Go medalist electric-non dcs Electric EZGO
1994 ezgo marathon electric $700 Golf Carts and Parts
1994 E-Z-GO Marathon Electric $1000 OBO Golf Carts and Parts
1994 ez go 36 volt electric Electric EZGO
electric club car 1994 Electric Club Car


All times are GMT -5. The time now is 05:01 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.