lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 04-06-2011, 08:00 PM   #1
Not Yet Wild
 
Join Date: Apr 2011
Posts: 3
Default 2006 does nothing

2006 does nothing at all. Serial AQ0607 Cart stopped doing anything. The backup buzzer doesn't work, no solenoid click, and charger wouldn't come on. I checked the batteries and one was bad, I put 4 new deep cycle marine batteries in ( borrowed from bass boat ) to make sure that would fix it but still get nothing. Key switch is good, tow/run switch good, battery pack voltage 50.8. Local cc shop says I may have blown a fuse. The only fuse
I can find is the one on the charger circuit. Any ideas what to check now.
raymac is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 04-07-2011, 09:33 AM   #2
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: 2006 does nothing

Tell us your story.
When did it stop.
What happened before it stopped.
What have U done since it stopped
The better the history and more detailed the faster the FIX

send picture of battery compartment and wiring in that area.
The closer the better.
GLEEMO is offline   Reply With Quote
Unread 04-07-2011, 12:07 PM   #3
Not Yet Wild
 
Join Date: Apr 2011
Posts: 3
Default Re: 2006 does nothing

Thanks for the reply Gleemo

Played golf with cart it worked fine with no problems, very hilly course and didn't notice any loss of power.
Came home put cart on charger, charger clicked on and went to approx. 11 amps which is where it would normallly always go, ever since I have had the cart.
Three days later went to get the cart to play golf, and unplugged it, pressed on the pedal and went about 3 inches.
Started troubleshooting the next day, and found the battery pack reading was a little over 48v resting, and dropped to below 40 when pedal was pushed. Took batteries loose and charged each individually. Found one of them bad. Hooked them back up and cart does nothing. No backup buzzer, no yellow battery light, nothing. Replaced batteries with
boat batteries and still nothing. Boat batteries are new and have pack reading of 50.8 v.
Still nothing will work. Charger will come on with obc bypassed. Tested on off switch it is good. Tested run/tow switch, it is good. Tested mcor, microswitch is good, reading from
pot section is white wire to purple, 5.84k ohms pedal not pressed, 5.84k ohms pressed, purple to yellow is 1.16k ohms pedal not pressed, 7.01 k ohms pressed, yellow to white is 7.01k ohms pedal not pressed, 1.15k ohms pressed. I don't know if this is normal or not?
Also tried jumping the solenoid nothing happened.
Picture of battery compartment is 2 photos, I couldn't get far enough away because of roof and camera turned one for some reason.
Attached Images
File Type: jpg bat1.jpg (68.5 KB, 8 views)
File Type: jpg bat2.jpg (41.8 KB, 7 views)
raymac is offline   Reply With Quote
Unread 04-07-2011, 12:49 PM   #4
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: 2006 does nothing

Have U checked the charger fuse under the yellow sleeve
GLEEMO is offline   Reply With Quote
Unread 04-07-2011, 01:21 PM   #5
Not Yet Wild
 
Join Date: Apr 2011
Posts: 3
Default Re: 2006 does nothing

Yes the fuse tests good.
raymac is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
2006 txt Electric EZGO
2006-08 CC DS with IQ Electric Club Car
2006 e z go txt Electric EZGO
2006 ez go Members Rides
2006 Ez Go Electric EZGO


All times are GMT -5. The time now is 12:59 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.