lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 05-03-2011, 06:34 PM   #1
Not Yet Wild
 
Join Date: May 2011
Posts: 2
Default Golf Cart suddenly quit running

We have a 1991 club car. The batteries are about 4 years old and check out okay.

We have been noticing a loss of power going up hill, but it runs fine on level ground.

Yesterday when running, it made a noise then quit.

Husband changed the solenoid but still no power.

any other suggestions?


Thanks!
krnlueck is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 05-03-2011, 10:06 PM   #2
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: Golf Cart suddenly quit running

welcome, 1st start with basics.....it only takes one bad cell in one battery to stop a cart......or 1 wire or cable...........91 has to be 36 volt start with a voltage meter and check voltage of each battery than the pack......than load test and check cells with a hydrometer and while your at it check cables make sure all intact and clean and tight........if your not sure write voltage #,s down and post them but this is where to start........also ckeck water levels and if needed distilled water only about 1/4 over plates.............................
shadowman is offline   Reply With Quote
Unread 05-04-2011, 07:13 PM   #3
Not Yet Wild
 
Join Date: May 2011
Posts: 2
Default Re: Golf Cart suddenly quit running

Thanks Shadowman.

Hubby has done all that and he says batteries are okay and cables are tight.

Any other suggestions?
krnlueck is offline   Reply With Quote
Unread 05-04-2011, 07:21 PM   #4
THE CUSTOM KID
 
custom carts's Avatar
E-Z-GO
 
Join Date: Oct 2008
Location: Tallahassee Florida
Posts: 820
Default Re: Golf Cart suddenly quit running

check the cables in the motor one of might of burned off
custom carts is offline   Reply With Quote
Unread 05-05-2011, 06:52 AM   #5
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: Golf Cart suddenly quit running

next would be soleniod.....do you hear a loud click when you press pedal? if not jack the rear up and jump the large post on soleniod see if cart runs......if it has 5 soleniods behind batteries its the one furthest left on drivers side.......................................
shadowman is offline   Reply With Quote
Unread 05-09-2011, 08:54 PM   #6
just leave me alone
 
GLEEMO's Avatar
Club Car
 
Join Date: Aug 2008
Location: Tennessee
Posts: 5,643
Default Re: Golf Cart suddenly quit running

Quote:
Originally Posted by krnlueck View Post
Thanks Shadowman.

Hubby has done all that and he says batteries are okay and cables are tight.

Any other suggestions?
U know U can't believe a word he says (least that what my wife says about me )

Get the voltage reading from each battery , and then across entire pack and
post them back here
GLEEMO is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
quit running Electric Club Car
86 Club Car suddenly started running Slow Electric Club Car
98 carry all quit suddenly Gas Club Car
Cart Just Suddenly Stops Running! Electric Club Car
1997 ezgo txt electric cart quit running need help Electric EZGO


All times are GMT -5. The time now is 11:36 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.