lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 05-20-2011, 08:16 PM   #1
Not Yet Wild
 
Join Date: May 2011
Posts: 7
Default 1999 48 volt club car IQ barely runs slow

I replaced all 6 batteries with trojan T185. Ireplaced the 5 wires connecting the batteries and it ran great. Put it on charge and the next morning it would barely run very very slow. Checked charger on another cart it is good. Does anybody have any idea what to try next.
BAMA1299 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 05-21-2011, 10:19 AM   #2
Gone Wild
 
OLD MEC's Avatar
Club Car
 
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: 1999 48 volt club car IQ barely runs slow

I hope you just pushed the wrong key when making post? 8 volt Trojans are T-860, T-875, T890?? not T-185 you showed?
Its possible you either have a incorrect battery connection or even the possibility of a defective battery? Go over all cable connections from passeger side plus going to solenoid and back to driver side rear battery pack ground.
Check each battery for proper full charge voltage 8.49, and pack voltage for 50.96.
OLD MEC is offline   Reply With Quote
Unread 05-21-2011, 12:10 PM   #3
Not Yet Wild
 
Join Date: May 2011
Posts: 7
Default Re: 1999 48 volt club car IQ barely runs slow

Correction on batteries they are T875 and the voltages have been checked with and without load and are ok.
BAMA1299 is offline   Reply With Quote
Unread 05-21-2011, 12:57 PM   #4
Getting Wild
 
Join Date: Feb 2011
Posts: 122
Default Re: 1999 48 volt club car IQ barely runs slow

When you say runs very very slow please describe more. I'm wondering if it accelerates normally then tops out at around 5 mph and goes steady but no faster?
Slats is offline   Reply With Quote
Unread 05-21-2011, 01:04 PM   #5
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 8,025
Default Re: 1999 48 volt club car IQ barely runs slow

1999 IQ huh? Got a serial number?
TahoeDawgZ71 is offline   Reply With Quote
Unread 05-21-2011, 01:45 PM   #6
Not Yet Wild
 
Join Date: May 2011
Posts: 7
Default Re: 1999 48 volt club car IQ barely runs slow

It's a 99 model and has a push button F-N-R so I thought it was an IQ. When you give it gas it starts very slow barely moving then gets to about 7 MPH but will not climb any kind of incline
BAMA1299 is offline   Reply With Quote
Unread 05-21-2011, 05:38 PM   #7
Gone Wild
 
OLD MEC's Avatar
Club Car
 
Join Date: Mar 2009
Location: South Texas
Posts: 2,391
Default Re: 1999 48 volt club car IQ barely runs slow

1999 CC with rocker switch is a REGEN 2 rather than a IQ which didnt start until about 2001.
OLD MEC is offline   Reply With Quote
Unread 05-21-2011, 06:28 PM   #8
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 8,025
Default Re: 1999 48 volt club car IQ barely runs slow

It's a 99 PowerDrive Plus, or Regen 2.. The IQ system was not released until 2002. Here's the first step. Remove access door and tell me whether you've got one or two solenoids. Then, if you do have 2, which you should, tell me if they're both clicking when you press the accel pedal. I'm guessing the Dynamic Braking solenoid, on the driver's side is stuck in the closed position and allowing all of the current to dissipate through the resistor coil. I'll bet you're only getting one click.
TahoeDawgZ71 is offline   Reply With Quote
Unread 05-22-2011, 10:22 AM   #9
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 1999 48 volt club car IQ barely runs slow

another sure way to tell is just take a look at the resistor coil on the braking soleniod if its glowing red than your problem is in that system......had a 96 do that to me drove me crazy at 1st but i found it......................
shadowman is offline   Reply With Quote
Unread 05-22-2011, 01:23 PM   #10
Not Yet Wild
 
Join Date: May 2011
Posts: 7
Default Re: 1999 48 volt club car IQ barely runs slow

First of all I would like to thank everyone for there help. Just got a chance to look at the cart. It does have 2 solenoid's and when I press the gas pedal I only get one click.
BAMA1299 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
'93 G9 Gas - barely runs after after electrical issue Gas Yamaha
89 parcar rebuild, barely runs..wrong piston? Gas Columbia ParCar
club car 48 volt runs slow Electric Club Car
1999 Club Car Slow to charge Electric Club Car
Club Car runs slow in reverse Electric Club Car


All times are GMT -5. The time now is 10:51 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.