lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 06-06-2011, 04:15 PM   #1
Not Yet Wild
Club Car
 
Join Date: Oct 2009
Location: syracuse ny
Posts: 9
Default need some help w/99 club car

99 club car won't move. Checked all the batteries-good. This is not a regen cart.Checked all fuses-good. Cart was working fine last weekend when parked,showed up this weekend and nothing.any help would be greatly appreciated. thanks
rumorz is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 06-06-2011, 04:36 PM   #2
Gone Wild
 
Join Date: Dec 2010
Posts: 458
Default Re: need some help w/99 club car

Quote:
Originally Posted by rumorz View Post
99 club car won't move. Checked all the batteries-good. This is not a regen cart.Checked all fuses-good. Cart was working fine last weekend when parked,showed up this weekend and nothing.any help would be greatly appreciated. thanks
Does the solenoid click when u press the accelerator pedal ? If not connect a jumper lead from the small post on the solenoid (where the yellow wire is attached) to the No.6 battery negative or the controller B- post and see if the cart goes. If it does then OBC is faulty or there is no continuity in the yellow wire from the solenoid to the OBC.
Golfdog is offline   Reply With Quote
Unread 06-06-2011, 04:56 PM   #3
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: need some help w/99 club car

is it a 48 volt cart or a 36 volt cart? how did you check the batteries? did you load test them? did you grab and tug cables to make sure all are tight and are they good and clean did you lose reverse buzzer as well..............did you put charger on and did it work...............oh welcome.......................
shadowman is offline   Reply With Quote
Unread 06-06-2011, 05:07 PM   #4
Not Yet Wild
Club Car
 
Join Date: Oct 2009
Location: syracuse ny
Posts: 9
Default Re: need some help w/99 club car

The cart is 48 volt. Tried the ground on the sol. I have done a load test, spec. gravity test, and all the terms are clean. batt. are only 2 years old.
rumorz is offline   Reply With Quote
Unread 06-06-2011, 05:07 PM   #5
Not Yet Wild
Club Car
 
Join Date: Oct 2009
Location: syracuse ny
Posts: 9
Default Re: need some help w/99 club car

Oh yeah thank you for the welcome.
rumorz is offline   Reply With Quote
Unread 06-06-2011, 05:09 PM   #6
Not Yet Wild
Club Car
 
Join Date: Oct 2009
Location: syracuse ny
Posts: 9
Default Re: need some help w/99 club car

Charger works ,cart never had a rev. buzzer since ive owned it.
rumorz is offline   Reply With Quote
Unread 06-06-2011, 05:17 PM   #7
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: need some help w/99 club car

ok have you tried jacking rear end up and jumping the soleniod? get a peice of 6 gage cable and jump across the large post of soleniod turn key on put in gear slowly press pedal see if cart runs........if so soleniod................
shadowman is offline   Reply With Quote
Unread 06-06-2011, 05:40 PM   #8
Not Yet Wild
Club Car
 
Join Date: Oct 2009
Location: syracuse ny
Posts: 9
Default Re: need some help w/99 club car

Tom, ye i have tried jumping the sol. w/ the wheels jacked up. Still no go.I have good voltage going across w/ no jumper also. Sol. just clicks.
rumorz is offline   Reply With Quote
Unread 06-06-2011, 05:40 PM   #9
Not Yet Wild
Club Car
 
Join Date: Oct 2009
Location: syracuse ny
Posts: 9
Default Re: need some help w/99 club car

Is it possable the controller went bad?
rumorz is offline   Reply With Quote
Unread 06-06-2011, 07:02 PM   #10
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: need some help w/99 club car

and you tried running a jumper wire from soleniod small post where yellow wire is over to #6 battery ground? how about your F&R have you tested that?........................................
shadowman is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes



All times are GMT -5. The time now is 07:49 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.