|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
06-06-2011, 03:15 PM | #1 |
Not Yet Wild
Join Date: Oct 2009
Location: syracuse ny
Posts: 9
|
need some help w/99 club car
99 club car won't move. Checked all the batteries-good. This is not a regen cart.Checked all fuses-good. Cart was working fine last weekend when parked,showed up this weekend and nothing.any help would be greatly appreciated. thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
06-06-2011, 03:36 PM | #2 |
Gone Wild
Join Date: Dec 2010
Posts: 488
|
Re: need some help w/99 club car
Does the solenoid click when u press the accelerator pedal ? If not connect a jumper lead from the small post on the solenoid (where the yellow wire is attached) to the No.6 battery negative or the controller B- post and see if the cart goes. If it does then OBC is faulty or there is no continuity in the yellow wire from the solenoid to the OBC.
|
06-06-2011, 03:56 PM | #3 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: need some help w/99 club car
is it a 48 volt cart or a 36 volt cart? how did you check the batteries? did you load test them? did you grab and tug cables to make sure all are tight and are they good and clean did you lose reverse buzzer as well..............did you put charger on and did it work...............oh welcome.......................
|
06-06-2011, 04:07 PM | #4 |
Not Yet Wild
Join Date: Oct 2009
Location: syracuse ny
Posts: 9
|
Re: need some help w/99 club car
The cart is 48 volt. Tried the ground on the sol. I have done a load test, spec. gravity test, and all the terms are clean. batt. are only 2 years old.
|
06-06-2011, 04:07 PM | #5 |
Not Yet Wild
Join Date: Oct 2009
Location: syracuse ny
Posts: 9
|
Re: need some help w/99 club car
Oh yeah thank you for the welcome.
|
06-06-2011, 04:09 PM | #6 |
Not Yet Wild
Join Date: Oct 2009
Location: syracuse ny
Posts: 9
|
Re: need some help w/99 club car
Charger works ,cart never had a rev. buzzer since ive owned it.
|
06-06-2011, 04:17 PM | #7 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: need some help w/99 club car
ok have you tried jacking rear end up and jumping the soleniod? get a peice of 6 gage cable and jump across the large post of soleniod turn key on put in gear slowly press pedal see if cart runs........if so soleniod................
|
06-06-2011, 04:40 PM | #8 |
Not Yet Wild
Join Date: Oct 2009
Location: syracuse ny
Posts: 9
|
Re: need some help w/99 club car
Tom, ye i have tried jumping the sol. w/ the wheels jacked up. Still no go.I have good voltage going across w/ no jumper also. Sol. just clicks.
|
06-06-2011, 04:40 PM | #9 |
Not Yet Wild
Join Date: Oct 2009
Location: syracuse ny
Posts: 9
|
Re: need some help w/99 club car
Is it possable the controller went bad?
|
06-06-2011, 06:02 PM | #10 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: need some help w/99 club car
and you tried running a jumper wire from soleniod small post where yellow wire is over to #6 battery ground? how about your F&R have you tested that?........................................
|