lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 06-22-2011, 11:31 PM   #61
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,079
Default Re: Foward in reverse and reverse in forward

David You are the man on Club Car. That's for sure ! I too feel it is a solenoid activation failure but am not at all familiar with the many ways this particular system can fail. Throwing the OBC ground control to solenoid in was unnecessary roughness. 15 yd penalty!





Thanks for helping us out!
scottyb is online now   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 06-23-2011, 08:16 AM   #62
Getting Wild
 
gabulldawg83's Avatar
Club Car
 
Join Date: May 2011
Location: Franklin GA
Posts: 121
Default Re: Foward in reverse and reverse in forward

after looking up the cost of an obc, i wouldnt mind TOO much if thats the problem. better than a six hundred dollar controller. is there a way to troubleshoot the obc rather than replacing it? do you think i fried it while making all the changes? like i said it was running fine before making all the changes.
gabulldawg83 is offline   Reply With Quote
Unread 06-23-2011, 09:28 AM   #63
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: Foward in reverse and reverse in forward

dawg, can he run a bypass to see if its OBC failure? the only reason i never mentioned this was he said cart was working fine before the upgrades ( i shoulda known better ) but if he can ...........run a jumper from soleniod small post where yellow wire is over to neg of #6 battery and see if cart will run.....if so than do as david says replace OBC its bad......................
shadowman is offline   Reply With Quote
Unread 06-23-2011, 09:30 AM   #64
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,079
Default Re: Foward in reverse and reverse in forward

David has sent me the service manual. Where do you get to when you follow this troubleshooting flow chart?

REGEN 2
Attached Images
File Type: jpg Capture Regen flow chart.JPG (75.1 KB, 58 views)
scottyb is online now   Reply With Quote
Unread 06-23-2011, 10:10 AM   #65
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,079
Default Re: Foward in reverse and reverse in forward

Here is OBC power test procedure.....

REGEN 2
Attached Images
File Type: jpg Capture Regen test procede 2.JPG (126.4 KB, 57 views)
scottyb is online now   Reply With Quote
Unread 06-23-2011, 01:06 PM   #66
Getting Wild
 
gabulldawg83's Avatar
Club Car
 
Join Date: May 2011
Location: Franklin GA
Posts: 121
Default Re: Foward in reverse and reverse in forward

thanks guys. im at work today. i dont get off until 0800 tomorrow. im definately going to try this.
gabulldawg83 is offline   Reply With Quote
Unread 06-23-2011, 02:25 PM   #67
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,079
Default Re: Foward in reverse and reverse in forward

Chris email me for the more info, if needed.

Talked with Tahoe this am, I told him what I posted & he feels the above info should sort your trouble out. Good Luck
scottyb is online now   Reply With Quote
Unread 06-23-2011, 04:56 PM   #68
Getting Wild
 
gabulldawg83's Avatar
Club Car
 
Join Date: May 2011
Location: Franklin GA
Posts: 121
Default Re: Foward in reverse and reverse in forward

ok im just looking over this trouble shooting chart and it says that if the solenoid has ower but doesnt click replace solenoid. well it doesnt click but i changed it out and with the factory solenoid and that didnt click either. i KNOW that factory one worked before i took it off. what are the chances that both of them fried?
gabulldawg83 is offline   Reply With Quote
Unread 06-23-2011, 06:01 PM   #69
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: Foward in reverse and reverse in forward

try bypassing the OBC......run a jumper wire from the main soleniod small post with yellow wire bolted over to the neg terminal of #6 battery see if cart runs.............................
shadowman is offline   Reply With Quote
Unread 06-23-2011, 06:13 PM   #70
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,079
Default Re: Foward in reverse and reverse in forward

Wait. Shadow assumes you know which post is positive and which is negative on the solenoid activation circuit.
scottyb is online now   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Reverse alarm sounds in Forward, wont go forward or reverse Electric Club Car
Reverse alarm stuck - motor won't run forward or reverse Electric EZGO
2 solenoids for a foward and reverse Electric Yamaha
No foward but i have reverse Electric Club Car
Need a different setup for foward and reverse Gas EZGO


All times are GMT -5. The time now is 10:05 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.