lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 07-05-2011, 08:34 AM   #11
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: club car iq problem

if batteries are all good and sensor is good it has to be in the speed system somewhere or the controller i would think....................................
shadowman is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 07-08-2011, 10:58 PM   #12
Not Yet Wild
 
Backwoods Bogger's Avatar
 
Join Date: Jun 2011
Posts: 27
Default Re: club car iq problem

still having problem with cart, it has lost speed and has very little power to get up hills
Backwoods Bogger is offline   Reply With Quote
Unread 07-09-2011, 08:06 AM   #13
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: club car iq problem

you have a F&R lever not the rocker switch right?......did you by chance check the motor brushes?............................
shadowman is offline   Reply With Quote
Unread 07-09-2011, 10:34 AM   #14
Not Yet Wild
 
Backwoods Bogger's Avatar
 
Join Date: Jun 2011
Posts: 27
Default Re: club car iq problem

i have the rocker switch with the data port under the bottom, also i have not checked the brushes
Backwoods Bogger is offline   Reply With Quote
Unread 07-09-2011, 10:39 AM   #15
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: club car iq problem

have you paid any attention to the resistor coil mounted either behind the batteries or on the 2nd soleniod? drive the cart a 100 ft or so and see if that coil is starting to glow red...........................
shadowman is offline   Reply With Quote
Unread 07-09-2011, 10:44 AM   #16
Not Yet Wild
 
Backwoods Bogger's Avatar
 
Join Date: Jun 2011
Posts: 27
Default Re: club car iq problem

i have looked but i only see one solenoid on mine, maybe i am just over looking it
Backwoods Bogger is offline   Reply With Quote
Unread 07-09-2011, 10:56 AM   #17
Gone Wild
Club Car
 
Join Date: Apr 2011
Location: Texas
Posts: 600
Default Re: club car iq problem

I do not think an iq cart has this solenoid I think it's done with controller
gaminde is offline   Reply With Quote
Unread 07-09-2011, 11:29 AM   #18
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: club car iq problem

Quote:
Originally Posted by gaminde View Post
I do not think an iq cart has this solenoid I think it's done with controller
i,m not 100% certain either but if it has one it should be rear drivers side if you have the access panel take it off and look it would be right there if it has a 2nd one......if it is done with the controller than problem may be with the controller...............i,m looking at 2 different diagrams one shows without 2nd soleniod one with 2nd soleniod..............both have run tow switch and rocker switches.......................................... .....
shadowman is offline   Reply With Quote
Unread 07-09-2011, 02:51 PM   #19
Not Yet Wild
 
Backwoods Bogger's Avatar
 
Join Date: Jun 2011
Posts: 27
Default Re: club car iq problem

i do not have the second solenoid, i put the volt meter on the pack and rode around, it seems to be holding steady at 48.6 volts, also my accelerator pedal moves alot before the solenoid clicks, the solenoid clicks about 1 inch from the floor, thinking this may be my problem is there anyway to adjust the pedal so the solenoid engages sooner?
Backwoods Bogger is offline   Reply With Quote
Unread 07-09-2011, 04:56 PM   #20
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: club car iq problem

the linkage should be adjustable....................................
shadowman is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
92 Club car run problem Gas Club Car
problem with 92 gas club car Gas Club Car
Club Car go problem Electric Club Car
Club Car problem Electric Club Car


All times are GMT -5. The time now is 05:23 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.