lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars

Post New Thread  Reply
Thread Tools Display Modes
Unread 07-18-2011, 07:45 AM   #1
Not Yet Wild
Join Date: Jul 2011
Posts: 2
Default 1987 DC Rescue

Recently completed a rescue of a 87 Club Car DS. 6 New Batteries, 6 Inch Lift, 22X11X10 Tires, Flip Seat and HD Springs. Nice little unit for the age and with the Aoooga Horn the Grand kids think I invented the wheel

The 4 of us were out in the woods over the weekend and noticed a strange incident. At times, High Speed would not cycle and even though the Batteries had a Full Charge....the cart went slowly. Seems that it becomes intermittent and unpredictable after only a short time of use. If the Micro Switches are working, I'm thinking Solenoid but which one?
Replace all to be sure?
How about cable that has had some heat through it? There is one (white one) that the insulation has bubbled. I guess there could be some Resistance issue....

I'm pretty handy, but not to sure of what may be the issue here. I did not put a meter on the Micro's but from the clicks.....I would guess their working as intended.

Any help would be greatly appreciated
FLSTS is offline   Reply With Quote
Alt Today

Golf car forum Sponsored Links

This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
Unread 07-18-2011, 07:59 AM   #2
The Last Moja Morani
shadowman's Avatar
Club Car
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 1987 DC Rescue

welcome to BGW...............jack the rear of the cart up and slowly press the pedal and listen as soleniods engage....1st on on drivers side left is master.....the rest are speeds 1 thur 2nd click wheels should slowly start spinning and as soleniod click they should spin,ll hear if one isn,t working..............its not a bad idea to replace them all if you can as that leaves you with some spares if far as cables if you have one getting hot it could be resistance and it won,t hurt to replace all cables might give you better preformance.....make sure your buss bar across the soleniods is good and clean and same with resister coils............have fun with it......disconnect main power before doing any hands on work............................
shadowman is offline   Reply With Quote
Unread 07-18-2011, 08:13 AM   #3
Not Yet Wild
Join Date: Jul 2011
Posts: 2
Default Re: 1987 DC Rescue

Thanks for the Welcome and thanks for the quick reply

Some quick web searches today shows the Solenoids are relatively inexpensive, so I'll probably swap them all. The Coils are rusty and I've done nothing to them. I'll pick up some cable and ends to replace them next trip to Camp!

Looks like Friendly folks here on BGW....I'll bounce around your very informational board for helpful tidbits!
FLSTS is offline   Reply With Quote
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car

Thread Tools
Display Modes

Similar Threads
Thread Forum
1987 cc Electric Club Car
1987 ez go won't run Electric EZGO
1987 ez go Electric EZGO
2001 EZ GO Hurricane Ike Rescue Need Info Please Electric EZGO
1987 Members Rides

All times are GMT -5. The time now is 07:56 PM.

Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2018, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.