lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 08-14-2011, 10:33 PM   #1
Gone Wild
 
Wynelocked's Avatar
E-Z-GO
 
Join Date: Jun 2008
Location: Sumner Washington
Posts: 208
Default 08 Club Car 48volt wont go...

Carts been fine up till now.Batterys read 44.8...checked each battery an get 11.8-12.2...4x12v batterys

When I put it in reverve...the buzzer goes off...but cart will not go.

Where do I start?I don't know squat about electric carts.
Wynelocked is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 08-14-2011, 11:02 PM   #2
Not Yet Wild
Club Car
 
Join Date: Mar 2009
Location: Northern Wisconsin
Posts: 48
Default Re: 08 Club Car 48volt wont go...

Start by reading the State of Charge chart above. Your batteries need charging or are shot.
sb2bb is offline   Reply With Quote
Unread 08-15-2011, 07:37 AM   #3
Gone Wild
 
Wynelocked's Avatar
E-Z-GO
 
Join Date: Jun 2008
Location: Sumner Washington
Posts: 208
Default Re: 08 Club Car 48volt wont go...

Quote:
Originally Posted by sb2bb View Post
Start by reading the State of Charge chart above. Your batteries need charging or are shot.
No doubt they need charging....but thats not it.These are Factory 08 Trogan built batterys.Carts been running fine up to now.I misspoke about the44.8...it was 48.4v...uncharged.
Wynelocked is offline   Reply With Quote
Unread 08-15-2011, 08:13 AM   #4
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 08 Club Car 48volt wont go...

is the soleniod clicking?......................................... ........
shadowman is offline   Reply With Quote
Unread 08-22-2011, 11:25 AM   #5
Gone Wild
 
Wynelocked's Avatar
E-Z-GO
 
Join Date: Jun 2008
Location: Sumner Washington
Posts: 208
Default Re: 08 Club Car 48volt wont go...

Quote:
Originally Posted by shadowman View Post
is the soleniod clicking?......................................... ........
Sorry for the absence...

No
Wynelocked is offline   Reply With Quote
Unread 08-22-2011, 12:40 PM   #6
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 08 Club Car 48volt wont go...

if soleniod isn,t clicking and battery voltage is good ( have you tried charging them since cart won,t move ) if not try charger to see if it works then jack the rear of cart up and put a jumper on large posts of soleniod than turn key on put in gear and press pedal see if wheels spin.......if so its either in the activation circuit or the soleniod went bad..............theres a better chance its the soleniod but not always 100%.............................
shadowman is offline   Reply With Quote
Unread 08-23-2011, 08:49 PM   #7
Gone Wild
 
Wynelocked's Avatar
E-Z-GO
 
Join Date: Jun 2008
Location: Sumner Washington
Posts: 208
Default Re: 08 Club Car 48volt wont go...

Quote:
Originally Posted by shadowman View Post
if soleniod isn,t clicking and battery voltage is good ( have you tried charging them since cart won,t move ) if not try charger to see if it works then jack the rear of cart up and put a jumper on large posts of soleniod than turn key on put in gear and press pedal see if wheels spin.......if so its either in the activation circuit or the soleniod went bad..............theres a better chance its the soleniod but not always 100%.............................

Hmmmm...I guess I have to do more research.I found the motor...but still looking for a solenoid of some kind.Nothing is very accessable on these Club Cars.
Wynelocked is offline   Reply With Quote
Unread 08-23-2011, 09:25 PM   #8
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 08 Club Car 48volt wont go...

soleniod should have two 6 gage cables going to it and than some smaller wires i,m not 100% certain where it located on your cart but its in there with the batteries somewhere......on the small side not quite as big as a pop can and either round or square,....................................
shadowman is offline   Reply With Quote
Unread 08-28-2011, 08:14 PM   #9
Gone Wild
 
Wynelocked's Avatar
E-Z-GO
 
Join Date: Jun 2008
Location: Sumner Washington
Posts: 208
Default Re: 08 Club Car 48volt wont go...

I'll shoot some pictures tomorrow.We can go from there....but after more reading...an questioning the lot manager...Me thinks he blew a controller.Cart was left in "run" mode when he messed with batterys.He told me he had a loud BOOM an acid went flying.Everything looks okay....but I'll dig further.
Wynelocked is offline   Reply With Quote
Unread 08-30-2011, 07:29 AM   #10
Mr. Helper
 
ForBruce's Avatar
Club Car
 
Join Date: May 2009
Location: NY Catskills & South carolina
Posts: 436
Default Re: 08 Club Car 48volt wont go...

i smell burnt controller..........

which controller do you have and what is the model # of it
ForBruce is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Converting 48volt yamaha charger to 1998 48volt club car Electric Club Car
99 48volt club car Electric Club Car
700amp 48volt ITS logisystems/48volt delta q charger Golf Carts and Parts
97 48volt clubcar series wired wont go Electric Club Car
97 club car 48volt Electric Club Car


All times are GMT -5. The time now is 02:07 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.