|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
08-18-2011, 05:39 AM | #1 |
Not Yet Wild
Join Date: Jul 2011
Posts: 10
|
2007 precedent stops at full pedal
I have a 2007 precedent IQ series cart.
Initially, it would not run at all. I changed the speed controller and still the same, so I changed the MCOR unit and now it will run but only about two thirds throttle. I also changed out the speed sensor. Any ideas? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-18-2011, 05:59 AM | #2 |
Medicare Recipient
Join Date: Jun 2011
Location: West Michigan
Posts: 3,541
|
Re: 2007 precedent stops at full pedal
Check for wear between GO pedal and MCOR input shaft where the "fork" from the input shaft meets the GO pedal . . . you should be able to see this by looking down from top of vehicle behind GO pedal . . . my 06 DS has wear at this point and required a shim at this mesh point to achieve full throttle (temp fix until I bring it home for winter) . . . some have used tubing over the "fork" for the forward motion to do same . . . good luck!
|
08-18-2011, 06:42 AM | #3 |
Not Yet Wild
Join Date: Jul 2011
Posts: 10
|
Re: 2007 precedent stops at full pedal
Thanks Steve, but I can't detect any wear. I hope am looking in the right place. I thinkyou are talking about the shaft that goes into the MCOR unit.
|
08-18-2011, 07:48 AM | #4 |
Medicare Recipient
Join Date: Jun 2011
Location: West Michigan
Posts: 3,541
|
Re: 2007 precedent stops at full pedal
Yes . . where the MCOR shaft mates with the GO pedal, viewing from above . . . there should be positive contact there with no space between pedal and MCOR "fork" . . . MCOR shaft should start to rotate with pedal instantly when depressed . . . mine did not rotate until pedal was almost half way to floor boards . . . it only takes 1/32" or less of space to create issues with being able to obtain full throttle . . .
|
08-18-2011, 08:44 AM | #5 |
Not Yet Wild
Join Date: Jul 2011
Posts: 10
|
Re: 2007 precedent stops at full pedal
I get an immediate response when I depress the pedal. Any other thoughts?
Thanks |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
05 precedent stops suddenly then starts working again | Electric Club Car | |||
EZ go just stops with slight hum when pedal is down | Electric EZGO | |||
Pedal stops working after a while | Electric EZGO | |||
Slows Down, Then Shutters at Full Pedal | Electric Club Car |