lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 09-09-2011, 11:46 AM   #11
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 2003 elec cc stops beeps then goes again

if its a reagan cart it has 2 soleniods.........do you have a rocker switch for F&R or a lever? rocker is a reagan if so it should be drivers side rear and will have a resistor coil mounted to it......if theres no back seat take the access cover off it should be right there..............................
shadowman is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 09-09-2011, 12:00 PM   #12
Not Yet Wild
 
Join Date: Sep 2011
Posts: 8
Default Re: 2003 elec cc stops beeps then goes again

It has a rocker switch and working on it before this looked up serial # and should be a regan, and found the solenoid you are referring to with resistor, but cannot locate another solenoid. Do you think I should try to reattach neg cable even though it arcs pretty big? Tow/ Run switch is a complete sealed unit including aluminum base for toggle switch
rum dude is offline   Reply With Quote
Unread 09-09-2011, 07:19 PM   #13
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 2003 elec cc stops beeps then goes again

your other soleniod the master should be on pass side mounted on horizontal frame rail.....................i would try 1 more time if it just arcs and you can finish putting it on do so but if it arcs and starts smokin or melting the terminal than back off.....................................
shadowman is offline   Reply With Quote
Unread 09-09-2011, 07:42 PM   #14
Not Yet Wild
 
Join Date: Sep 2011
Posts: 8
Default Re: 2003 elec cc stops beeps then goes again

thanks again Shadowman, I unplugged the tow/Run switch which finally killed all power, then connected neg battery cable, then plugged T/R switch back into harness, turned the key on, put in forward and mashed pedal and wheels turned for a couple of seconds in forward but not in reverse. Then checked motor controller and getting no power from MC to the motor. I ordered a rebuilt one from Golframa. Will let you know after I install it. I am still puzzled how MC could cause so many different problems, such as power on with T/R switch set to tow. T/R switch could still be bad
rum dude is offline   Reply With Quote
Unread 09-09-2011, 10:15 PM   #15
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 2003 elec cc stops beeps then goes again

are you certain your batteries are good? remember they can hold voltage and still be bad under load so for the heck of it load test each one....... it only takes one to fudge things up.......................................
shadowman is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
2003 pds under a load stops but starts back after short cool down Electric EZGO
2001 ezgo PDS stops, beeps, then goes Electric EZGO
2003 PDS 36 Volt Stops Running Electric EZGO
2004 EZGO Stops/Starts Beeps Electric EZGO
2003 electric EZGO randomly stops while driving. Electric EZGO


All times are GMT -5. The time now is 03:17 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.