|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
11-15-2011, 02:22 PM | #1 |
Not Yet Wild
Join Date: Aug 2011
Posts: 9
|
86 elec. Cc, battery boondoggle 36v.
Anyone have any idea why 2 of the 6 batteries won't charge? The two on the far right under the passenger side don't want to charge in a pack, when charged seperately (as 1-12v) they seem to be charging. They are all same manf. Same date of purch. New this summer and not used alot till hunting season,now in colder weather i have lost power to climb even slight grades. They recover enough in an hour or so to turn the thing around and limp home defeated.the charger is old too, but the other batts. Seem quite happy to be fed from it, and they hold their charge of just a little over 6v until used awhile. Warmer weather power was good,but it hasnt been much below 32deg. And not for long,plus the cart is garaged. The voltage on the two suspect batts. Does drop off slowly in the pre,post, and static test i did,while a third control batts,voltage remains steady 6.15 at static. Is it possible i have 2 defective batteries? Is it the cooler weather, or am i barking up the wrong tree?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-15-2011, 02:25 PM | #2 |
Medicare Recipient
Join Date: Jun 2011
Location: West Michigan
Posts: 3,541
|
Re: 86 elec. Cc, battery boondoggle 36v.
1. Load test all batteries.
2. Try changing the 2 "bad" one's location in the pack. 3. Double check all connections for being properly wired and tight. That's a start . . |
11-15-2011, 02:26 PM | #3 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 86 elec. Cc, battery boondoggle 36v.
are you sure the charge receptical wires are hooked to the right batteries? in most cases when you get the same one that for some reason isn,t charging its because someone took the wires off and put them back on in the wrong place.........and if the other battery is the one that is connected to the 1st one than both won,t charge..............make sure those wires are hooked in the right places.................................
|
11-15-2011, 02:56 PM | #4 |
Not Yet Wild
Join Date: Aug 2011
Posts: 9
|
Re: 86 elec. Cc, battery boondoggle 36v.
shadowman, i think you've got it, i looked and i am charging from the first to the fourth, where the reverse cable goes, no wonder itll still go in reverse huh? i'm thinking i need to take the smaller wire from the charger recpt. which is piggybacked with the reverse cable,on the direction controller to the fourth battery, and move it to the controller term. that connects the sixth battery, for forward running, am i making any sense? i guess i was trying to push a charge into those last two batteries,from the fourth, with no way for it to flow thru, wasn't gonna happen, right? thanks.
|
11-15-2011, 03:03 PM | #5 |
Not Yet Wild
Join Date: Aug 2011
Posts: 9
|
Re: 86 elec. Cc, battery boondoggle 36v.
thanks steve, i appreciate the rapid response,but then again that's the standard for the u.s.m.c.! thanks for your help, and for your service to our country. semper fi.
|
11-15-2011, 03:45 PM | #6 |
Medicare Recipient
Join Date: Jun 2011
Location: West Michigan
Posts: 3,541
|
Re: 86 elec. Cc, battery boondoggle 36v.
|
11-15-2011, 05:00 PM | #7 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 86 elec. Cc, battery boondoggle 36v.
yes you need the pos 10 gage wire from charge receptical to go to the pos term. of #1 battery and the 10 gage neg wire from charge receptical to the neg. term of #6 battery and then you,ll charge the whole pack............................
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Elec vs. Gas? | Electric Yamaha | |||
New to Me E Z Go 36v elec. | Electric EZGO | |||
From elec. to gas | Lifted Golf Carts | |||
85A Elec may not be 85? | Electric Club Car | |||
Have a 98 ez go elec that will not go | Electric EZGO |