forward/reverse wiring

BRV1960

Does anyone have the wiring diagram for an 07 DS 4 battery 48 volt forward/reverse switch? I have a blue, orange and a brown wire that goes to the forward/reverse switch. My charger won't charge and my resetting of my OBC won't make the buzzer buzz after 30 seconds through the reset. Although the cart does go forward and back okay it will not charge since I put it back together. I posted earlier but have thought that maybe this is the problem. Thanks.

BGW

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum

shadowman

charging should have nothing to do with the F&R switch...........what all did you do? is the run/tow switch on run? although i think it should charge in tow also.......anyways was some work done?.......................................

BRV1960

Yes, I took the batteries out, then the body, seats, roof off then had some welding done on it. Had the body repainted and then put it all back together. The cart works fine but the charger won't charge. I have checked the currents across the receptacle and it's good. The charger worked before I took the cart apart as I charged the batteries before I took the body apart. I also put a speed kit on the motor from speedydirect.com but have taken that off in case that was the problem. Did have the reverse switch apart but failed to mark down the wiring (da). I just hooked it up like I thought it was and it seemed to work so assumed it was correct as I had reverse (with buzzer) and forward. Just can't seem to figure this one out. I thought perhaps this may be the problem. I tried a different charger as well but it didn't work either. So I'm thinking I have some other problem (wiring I suppose).

shadowman

did you hook your 10 gage charging wires back to the batteries?..................................

Stevegrmich

scottyb

I''m not familiar with an 07DS but there is usually a fuse for the OBC somewhere at the receptacle or the solenoid or in some carts at both places.

shadowman

the one at receptical should be good if cart is running ..............i don,t know how the one in the grey wire effects things but i have never seen that fuse in grey wire go bad...........................................