lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 12-28-2011, 04:07 PM   #1
Not Yet Wild
 
Join Date: Dec 2011
Posts: 6
Default 08 Precedent DOA

Any help would be greatly appreciated. I have a 2008 Club Car Precedent Electric. Key switch is working, power on both sides of Run/Tow Switch. Mcor is sending power during pedal press (2 pin plug). Checked the Motor Controller (Curtis 1510-5201) and Found that Pin 1 Has no power which is the wire that goes to the power side of the 3 pin plug on the Mcor. From my understanding, the three pin switch going to the Mcor is Power, signal and ground. The switch tests good as far as ipedence on the signal side of the switch and the ground is good to on the 3 pin plug (Mcor) as well. Is this a bad Motor Controller? Or is there something else for me to check?

Last edited by blankjw; 12-28-2011 at 04:11 PM.. Reason: specify pin out
blankjw is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 12-29-2011, 02:04 PM   #2
Gone Wild
 
Join Date: May 2009
Posts: 230
Default Re: 08 Precedent DOA

blankjw,...You have done a lot of testing but you said nothing about the batteries and totla voltage. If you measure voltage from last battery ground to the key switch you should see the 48 volts on and off. Also you did not mention the forward/neural/reverse switch. Also, some place in the loop is a fuse. Does the charger work on the unit. To activate the controller I have found if I ever disconnect one battery in the loop and then reconnect it. I have to put the f/r switch in good position and then press the petal to get the controller to kick in. It actually takes abuout 5 seconds.
trigger1937 is offline   Reply With Quote
Unread 01-12-2012, 01:14 PM   #3
Not Yet Wild
 
Join Date: Dec 2011
Posts: 6
Default Re: 08 Precedent DOA

The voltage is good. Reading over 49 Volts. The Charger is working and the all fuse links are good. Also checked the resistor which is also good. Does the pin I spoke of (above) send power to the pedal?
blankjw is offline   Reply With Quote
Unread 01-12-2012, 01:36 PM   #4
Not Yet Wild
 
Join Date: Dec 2011
Posts: 6
Default Re: 08 Precedent DOA

Does anyone have a wiring schematic or troubleshoot guide I could download for the MCOR and OBC on this 2008 Precedent (Electric). Thank you
blankjw is offline   Reply With Quote
Unread 01-12-2012, 04:40 PM   #5
Getting Wild
Club Car
 
Join Date: Nov 2011
Location: ohio
Posts: 119
Default Re: 08 Precedent DOA

Go to http://bennettgolfcars.ca/ and click on manuals and then click on club car.In the third column.
rich6111 is offline   Reply With Quote
Unread 01-12-2012, 05:20 PM   #6
Not Yet Wild
 
Join Date: Dec 2011
Posts: 6
Default Re: 08 Precedent DOA

Thanks, but that's just a manual with parts listings. I need more of a service manual. Again, thanks for the help though.
blankjw is offline   Reply With Quote
Unread 01-12-2012, 05:22 PM   #7
Not Yet Wild
 
Join Date: Dec 2011
Posts: 6
Default Re: 08 Precedent DOA

Update: After reading a few posts, I performed the OBC reset procedure with no luck. The reverse buzzer doesn't make a sound. Did notice though, that the battery light will come on when I press on the accelerator. Only comes on for a couple seconds then goes back off and doesn't do it often. Mainly after disconnecting and reconnecting power. Any ideas?
blankjw is offline   Reply With Quote
Unread 01-12-2012, 05:52 PM   #8
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 08 Precedent DOA

Is the solenoid clicking when you hit your go peddle? If not have you tried jumping the large post on it? And for the heck of it have you tried plugging your charger in to see if it comes on?.............................
shadowman is offline   Reply With Quote
Unread 01-12-2012, 05:53 PM   #9
Gone Wild
 
erict's Avatar
Club Car
 
Join Date: Sep 2011
Location: East Michigan
Posts: 1,305
Default Re: 08 Precedent DOA

Quote:
Originally Posted by blankjw View Post
Thanks, but that's just a manual with parts listings. I need more of a service manual. Again, thanks for the help though.
Manuals?
erict is offline   Reply With Quote
Unread 01-12-2012, 06:08 PM   #10
Not Yet Wild
 
Join Date: Dec 2011
Posts: 6
Default Re: 08 Precedent DOA

Quote:
Originally Posted by shadowman View Post
Is the solenoid clicking when you hit your go peddle? If not have you tried jumping the large post on it? And for the heck of it have you tried plugging your charger in to see if it comes on?.............................
Charger works fine. And the solenoid is fine. I didn't jump across the larger posts, but I did test the solenoid with ground trigger. The controller isn't triggering the solenoid when I press the "go pedal". That's why is was wondering about the pin configuration on the controller. In my first post, I was asking about the controller sending power to the MCOR (go pedal). I don't see any power going to the MCOR. Thanks again.
blankjw is offline   Reply With Quote
Reply

Tags
curtis 1510a-5251, mcor
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
My new toy...08 Precedent Members Rides
04 Precedent Help me Electric Club Car
06 Precedent won't go Electric Club Car
Precedent vs DS Electric Club Car
Precedent Electric Club Car


All times are GMT -5. The time now is 04:19 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.