|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
01-05-2012, 08:20 PM | #1 |
Not Yet Wild
Join Date: Jan 2010
Posts: 2
|
86 DS Carryall wont move
I have a 86 DS with 5 micros and 5 solenoid 36v system. It will not move, on the ground or in the air. The first two solenoids click but no movement. I can hear the micros clicking for the third, fourth, and fifth solenoids. Any info would be helpful. Thanks
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
01-05-2012, 09:44 PM | #2 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 86 DS Carryall wont move
leave it jacked up............are you sure the 1st solenoid is clicking? drivers side furthest left is master..........even if its clicking it can still be bad so try jumping the large post on it see if cart runs, once you have large post jumped turn key on put in gear press pedal see if cart runs.................if so from your post you should have at least 1st speed ( solenoid next to master ) wheels should spin slow.......................try and get them worked out also look at buss bar and resistor coils..........the micro,s are in the silver box with red end caps on the left front area of frame.......so try and get solenoids worked out and after that it would be micro,s..................if micro,s are clicking chances are they are good but again possible 1 or more of them could be bad....................lastly check your wires going to solenoids.......the wires bolted to small solenoid post just make sure you have none broken or screwed up................................................ .....
|
01-07-2012, 09:35 AM | #3 |
Not Yet Wild
Join Date: Jan 2010
Posts: 2
|
Re: 86 DS Carryall wont move
I jump the main and still no movement.
This problem occurred after climbing a hill with three people onboard. Could this be the motor? |
01-07-2012, 09:42 AM | #4 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 86 DS Carryall wont move
yes its possible.....carefully take off cables and mark them the cables are double nutted 1 under cable and 1 holding cable on............when you get motor off take a good look you should be able to tell..........if you look in the stickies there should be directions on testing the motor...........................
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
Help-'82 DS wont move | Electric Club Car | |||
ez go wont move! | Electric EZGO | |||
Help Carryall wont move!! | Electric Club Car | |||
05 club car wont move | Electric Club Car | |||
2007 club car carryall won't move after being towed | Electric Club Car |