lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 01-22-2012, 07:55 PM   #11
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 48 volt club car big time problems!

battery side neg i beleive......there should be some directions in the stickies if you want to confirm.....or if someone else reads this they,ll jump in and either confirm or correct me..............................
shadowman is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 01-22-2012, 08:48 PM   #12
Not Yet Wild
 
Join Date: Jan 2012
Posts: 70
Default Re: 48 volt club car big time problems!

Ok, Just disconnected fuse and jumped to neg batt post. Bingo, charger is happily charging at 7 amps. I guees I should wait till fully charged, reset obc, and if still problems pull motor? Thanks again
biminibrad is offline   Reply With Quote
Unread 01-22-2012, 10:16 PM   #13
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 48 volt club car big time problems!

ok your charger isn,t going to shut off don,t leave it on any longer than 16 hours......you need to replace OBC and that will take care of charging issues and maybe other issue as well....................................
shadowman is offline   Reply With Quote
Unread 01-23-2012, 06:23 PM   #14
Ban Puppy Mills & Stores!
 
scubabud's Avatar
Club Car
 
Join Date: Dec 2008
Location: SE Florida
Posts: 2,945
Default Re: 48 volt club car big time problems!

My Precedent motor did the same thing... turned out to be a broken spring on one of the brushes. When pushed it would try to move but very jerky. So part of your problem might be the motor!
scubabud is offline   Reply With Quote
Unread 01-23-2012, 07:50 PM   #15
Not Yet Wild
 
Join Date: Jan 2012
Posts: 70
Default Re: 48 volt club car big time problems!

ok, More info. Pulled the motor and has major issues, burnt stuff and what not. The motor is a d and dmotor works, model 170-012-0002, rating class h, 36 volts. My club car is a 48 volt set up. What happens then, any advise on replacement motors appreciated. Thanks, Brad BTW RESET OBC AND CHARGER KICKED ON, WOULD A FRIED MOTOR AFFECT THE OBC AND CHARGING OR DO I STILL HAVE MULTIPLE PROBLEMS?
biminibrad is offline   Reply With Quote
Unread 01-23-2012, 08:03 PM   #16
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 48 volt club car big time problems!

it should not effect the OBC but who knows......its fine to run a 36 volt motor in a 48 volt cart lots of us have that setup....36 volts gives you approx 25% more bang..........this is more than likely a coincidence..............as long as cart is charging concentrate on motor and if charging system acts up again than worry about it................................
shadowman is offline   Reply With Quote
Unread 01-23-2012, 08:36 PM   #17
Not Yet Wild
 
Join Date: Jan 2012
Posts: 70
Default Re: 48 volt club car big time problems!

ok, thanks. my goal at this point is to have a top speed of 15mph, all flat. What motor should I be looking for? do I need to worry about number of splines etc? Thanks again
biminibrad is offline   Reply With Quote
Unread 01-23-2012, 08:49 PM   #18
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 48 volt club car big time problems!

yes you have to get one that matches up , if you get the 36 volt motor you have repaired that should give you 16 to 18 mph........................other than that a PQ motor will do it......you can also send yours to PQ and have them do it....................................
shadowman is offline   Reply With Quote
Unread 02-03-2012, 11:31 AM   #19
Not Yet Wild
 
Join Date: Jan 2012
Posts: 70
Default Re: 48 volt club car big time problems!

Ok, update. Replaced motor, cart runs smooth and fast enough. After use put on charger. Charger would not come on. Disconnected one battery cable, put back on, it is charging now. If I use it and put charger on and it does not come on then what? Thanks. FYI been spreading the word here in the Bahamas, we have so many broken carts it is ridiculous!
biminibrad is offline   Reply With Quote
Unread 02-03-2012, 01:27 PM   #20
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 48 volt club car big time problems!

thanks for the update..............ok if you havn,t replaced the OBC thats what your gonna have to do and that will take care of the charging issue......i think i told you there might be more than 1 problem so you should be fine after that..............................
shadowman is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Problems with converting 36 volt cart to 48 volt NEED HELP Electric Club Car
48 volt Txt problems Electric EZGO
Charging time 36 volt Club Cart Electric Club Car
What is time to recharge on volt meter? Electric Club Car
99 48-volt club car problems Electric Club Car


All times are GMT -5. The time now is 12:04 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.