lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 01-29-2012, 02:20 PM   #1
Not Yet Wild
 
Join Date: Jan 2012
Posts: 7
Default car sticking

I have a 86 club car that sticks in gear. You can shut the key off and it will stop some time. I appears to do it worse when the batteries are weak. I also have noticed that when you charge it that 3 batteries sound like they are boiling. 1st question is how do I determin which sioloid is sticking? 2nd question is do I have a battery going bad when it sound like it is boiling?
firefighter2024 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 01-29-2012, 03:15 PM   #2
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: car sticking

its your furthest left solenoid thats the master.......as for batteries just fill with distilled water charge and let sit 8 hours than check voltage with a digital voltage meter and then load test each one....noise dosn,t mean much lots of batteries spit and fart when being charged..........wouldn,t you with some voltage rammed up your rear.............lolol....................
shadowman is offline   Reply With Quote
Unread 01-29-2012, 03:51 PM   #3
Not Yet Wild
 
Join Date: Jan 2012
Posts: 7
Default Re: car sticking

furtherest left looking from the front?
firefighter2024 is offline   Reply With Quote
Unread 01-29-2012, 04:07 PM   #4
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: car sticking

yep its the only one that dosn,t have a resistor coil mounted on top..........................
shadowman is offline   Reply With Quote
Unread 01-29-2012, 08:59 PM   #5
Not Yet Wild
 
Join Date: Jan 2012
Posts: 7
Default Re: car sticking

mine is on the right then. I'm looking at the wiring diagram and It shows a white wire on the motor side of the silinoid and then 2 white wires on the last one. I had a problem with the cart running full speed with the key on and off and found it to be the switch. I replaced the 5 silinoids and the wire going to the motor as they were melted. I can ride it for ~30 min and then it will hang. Do you think the problem will work out or do I need to replace it again
firefighter2024 is offline   Reply With Quote
Unread 01-29-2012, 09:00 PM   #6
Not Yet Wild
 
Join Date: Jan 2012
Posts: 7
Default Re: car sticking

I also would like to thank you for the help
firefighter2024 is offline   Reply With Quote
Unread 01-29-2012, 10:16 PM   #7
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: car sticking

no but if its running without even putting key in its the furthest left solenoid........if your looking at cart from front its on drivers side.....the last one on other side is a speed unless someone wrired it backwards......can you post any pics?....................................
shadowman is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
G1 throttle sticking / governor sticking Gas Yamaha
Brakes sticking or something else? Gas Yamaha
Brake sticking Electric EZGO
accelarator sticking Electric EZGO
Sticking Accelerator Electric Club Car


All times are GMT -5. The time now is 02:26 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.