|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
02-14-2012, 08:44 AM | #1 |
Not Yet Wild
Join Date: Nov 2010
Location: Northeast Ohio
Posts: 62
|
1994 reverse is ??
Hello!
Have a 1994 DS 36 volt with a v-glide. When lever is in reverse, you push the pedal down only about an inch and the cart will go in reverse. However, if the pedal is pushed down any farther, the cart will stop in reverse and not continue any farther. The cart does run in forward regardless of the position of the pedal. What do you all think? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
02-14-2012, 09:02 AM | #2 |
Happy Carting
Join Date: Dec 2007
Location: Southern California
Posts: 73,358
|
Re: 1994 reverse is ??
Use a multimeter (DMM) to check the Forward micro switch at the F&R. Next open and inspect the V-glide.
|
02-14-2012, 09:48 AM | #3 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 1994 reverse is ??
The following comment is based on the assumption that this car is a true V-Glide car with resistors behind the battery pack, and NOT a solid state controller car with a V-glide style potentiometer.
It Sounds like a weak battery pack to me. Reverse only runs off of 18 volts, which is barely enough to make the car move to begin with in my opinion. Even with a fully charged good set of batteries reverse will be weak for this reason. Forward runs on the full 36V pack. It's probably weak as well, but not weak enough to keep the car from running. You should see a green wire coming off of your F&R switch to battery number 4 positive. Move it to battery number 1, the same post as the red wire. It's the forward-most passenger side battery. This will give reverse full power. I'll bet it runs as good as forward |
02-14-2012, 11:50 AM | #4 |
Not Yet Wild
Join Date: Nov 2010
Location: Northeast Ohio
Posts: 62
|
Re: 1994 reverse is ??
okay so the cart does NOT have resistors. Also, we just installed the Crown batteries but will still attempt the above suggestion. You never know...will check back shortly
|
02-14-2012, 01:27 PM | #5 |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 1994 reverse is ??
how was the cart before you put batteries in? same way or did this happen after battery install?.................................
|
02-14-2012, 09:41 PM | #6 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 1994 reverse is ??
What's your battery pack voltage? If it's good, try unplugging the black and white wires from the rear-most micro switch located behind the F&R Switch and see if that does the trick. You may have a failed half-speed reverse resistor.
|
02-15-2012, 10:29 AM | #7 |
Not Yet Wild
Join Date: Nov 2010
Location: Northeast Ohio
Posts: 62
|
Re: 1994 reverse is ??
To answer the question about the batteries, the cart had bad batteries in it so that is the reason for the new Crown batteries. The cart did not run prior.
So we have fully retested the batteries and they are in great condition. We are going to try TahoeDawgs last reply in regards to the black and white wires from last microswitch. Will let you know the results. |
02-15-2012, 11:16 AM | #8 | |
The Last Moja Morani
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
|
Re: 1994 reverse is ??
Quote:
|
|
02-15-2012, 02:14 PM | #9 |
Not Yet Wild
Join Date: Nov 2010
Location: Northeast Ohio
Posts: 62
|
Re: 1994 reverse is ??
ok so great news!! By disconnecting the 3rd microswitch closest to the back, the cart runs in reverse full 36volts. Sooooooo, we replaced the microswitch and that took care of the problem. Isn't it a great feeling when another cart is repaired!! Thanks for ALL of your help and further educating us!!God Bless
|
02-15-2012, 02:23 PM | #10 |
Medicare Recipient
Join Date: Jun 2011
Location: West Michigan
Posts: 3,541
|
Re: 1994 reverse is ??
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
wiring a reverse light to the reverse buzzer? | Gas Yamaha | |||
Reverse won't go but if I pump gas it slams into reverse | Electric Club Car | |||
Reverse alarm stuck - motor won't run forward or reverse | Electric EZGO | |||
1994 Marathon vs 1994 TXT and newer | Electric EZGO | |||
1994 Ezgo electric runs great in reverse but does not forward | Electric EZGO |