Buggies Gone Wild Golf Cart Forum

Buggies Gone Wild Golf Cart Forum (http://www.buggiesgonewild.com/)
-   Electric Club Car (http://www.buggiesgonewild.com/electric-club-car/)
-   -   charger will not come on when plugged into cart 48 ds 95 cc (http://www.buggiesgonewild.com/electric-club-car/61867-charger-will-not-come-when-plugged-into-cart-48-ds-95-cc.html)

toogood4ubalius79 03-25-2012 08:38 PM

charger will not come on when plugged into cart 48 ds 95 cc
 
Had a bad thunderstorm the other night and came to find my cart had the yellow light on when i unplugged it i figured it was just because the charge was interrupted any help will be great thanks in advance. power drive club car charger model 17930 48 volt

shadowman 03-25-2012 09:09 PM

Re: charger will not come on when plugged into cart 48 ds 95 cc
 
1st thing is make sure battery voltage is good, over 36 volts thats what you need for charger to come on than check your fuse on front of charger and on cart charge receptical if both good try and verify charger works on another cart if you can.......is cart still running?..................................8)

toogood4ubalius79 03-25-2012 10:08 PM

Re: charger will not come on when plugged into cart 48 ds 95 cc
 
thanks shadow been a while since i been on this site.. yes cart is running fine and battery meter was full today before wife got on it and it only lost one bar in the 20 minutes she rode it.. the glass fuse looks fine unless they can break and not be noticeably but other then that what could be up.. i do not have a another 48 cart to try on... if i had less then 36 volts i would had notice her going really slow correct..if lighting would have hit my shed and the cart ran fine should it be the charger then or should i look else where. the power supply was good at the wall rec. the charger had a 15 amp breaker but i didn't know how to reset it or can you even do that on that charger or do you replace it.
thanks in advance

shadowman 03-26-2012 07:39 AM

Re: charger will not come on when plugged into cart 48 ds 95 cc
 
if it poped the breaker you just puch the button back in or if its a little toggle just press it sideways...........you can also open the charger and bypass the low voltage relay to see if its an OBC problem ( if you bypass and charger works its an OBC ) or if in fact its a charger problem but if it was plugged into cart i would try and make certain its one or the other......there should be directions in the stickies for bypassing that relay...........also lift the seat and give the grey wire a tug make sure it dosn,t pull out of receptical......if it does thats the problem...............there should be testing in stickies for charger componants also.......................8)

toogood4ubalius79 03-26-2012 07:54 AM

Re: charger will not come on when plugged into cart 48 ds 95 cc
 
I tugged on gray wire and check that fuse as well and I have no power to charger. Can I try any 48 volt charger if i can to rule out obc. I did some reading last night on power drive web site and they said something about plugging dc into cart and then 2 to 15 sec you would hear something close after plugging ac cord in. Thanks shadow I need to get a fix. Ps I check pack voltage 49.7 that was after she rode it

shadowman 03-26-2012 07:57 AM

Re: charger will not come on when plugged into cart 48 ds 95 cc
 
yes you can try antother 48 volt charger as long as it plugs into cart......if the charger works than you know its in your charger and not cart if it dosn,t work you know you have a cart problem.............................8)

toogood4ubalius79 03-26-2012 12:11 PM

Re: charger will not come on when plugged into cart 48 ds 95 cc
 
i tried another charger on my cart and nothing happened and i tried my charger on another cart and my charger had juice so i guess it would be obc is that correct? if so would part no. be 21750-01 thanks

shadowman 03-26-2012 12:23 PM

Re: charger will not come on when plugged into cart 48 ds 95 cc
 
yes more than likely OBC........what color is your dash battery light? is it red? if so that would indicate that its the original OBC in the cart and when you buy a new OBC it will come with a new orange battery light and a new grey wire.......you don,t have to put either of them in but i would change the light......if your light is orange already that would indicate that OBC has been changed at least once...............................8)

toogood4ubalius79 03-26-2012 12:58 PM

Re: charger will not come on when plugged into cart 48 ds 95 cc
 
Shadow thanks right off.. I changed Obc maybe year ago and had no warning light on dash but I put one in with new obc and it was orange that light tells us alot of information if you read up on it. I looked at some sites sponsors and I couldn't punch the part number and get any information on the OBC

Stevegrmich 03-26-2012 01:02 PM

Re: charger will not come on when plugged into cart 48 ds 95 cc
 
Quote:

Originally Posted by toogood4ubalius79 (Post 705799)
Shadow thanks right off.. I changed Obc maybe year ago and had no warning light on dash but I put one in with new obc and it was orange that light tells us alot of information if you read up on it. I looked at some sites sponsors and I couldn't punch the part number and get any information on the OBC

Try calling site sponsors for info . . make sure you mention BGW for any applicable discount . . :thumbup:


All times are GMT -5. The time now is 02:11 AM.

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2019, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. 2006-2017 Buggiesgonewild.com. All rights reserved.