lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 04-05-2012, 09:29 AM   #21
Medicare Recipient
E-Z-GO
 
Join Date: Jun 2011
Location: West Michigan
Posts: 3,543
Default Re: Wiring a 25 amp voltage reducer

Below is a link to reducer I purchased/installed . . note yellow wire, the trigger/control wire . . this simplifies installation . . the yellow wire is connected to the "cold" side of keyswitch so when key is turned on, power is supplied to trigger wire which in turn tells reducer to "power up" . . when keyswitch is turned off, trigger wire tells reducer to "power off" . . .

http://www.ebay.com/itm/190530622956...4.m1497.l2649=

The 12v output (green wire) was routed to a fuse block for my accessores, providing separate fuses for each one . . .
Stevegrmich is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 04-05-2012, 09:35 AM   #22
Not Yet Wild
 
Join Date: Feb 2012
Posts: 35
Default Re: Wiring a 25 amp voltage reducer

My reducer only has + battery - battery 12v pos 12v neg reducer model 9020 25amps
Scorchin Scooter is offline   Reply With Quote
Unread 04-05-2012, 10:16 AM   #23
Medicare Recipient
E-Z-GO
 
Join Date: Jun 2011
Location: West Michigan
Posts: 3,543
Default Re: Wiring a 25 amp voltage reducer

Quote:
Originally Posted by Scorchin Scooter View Post
My reducer only has + battery - battery 12v pos 12v neg reducer model 9020 25amps
It may be easier for you to not attempt to wire it to your keyswitch, but to add a different switch inline with one of the two wires that are connected to your pack . . . maybe a lighted rocker switch on the dash . . . the only pitfall is remembering to turn it off when not needed . . .
Stevegrmich is offline   Reply With Quote
Unread 04-05-2012, 10:59 AM   #24
Not Yet Wild
 
Join Date: Feb 2012
Posts: 35
Default Re: Wiring a 25 amp voltage reducer

I figured it out Thanks
Scorchin Scooter is offline   Reply With Quote
Unread 04-05-2012, 12:09 PM   #25
Gone Wild
 
89GatorClub's Avatar
Club Car
 
Join Date: Mar 2012
Location: Palatka, Fl
Posts: 799
Default Re: Wiring a 25 amp voltage reducer

Quote:
Originally Posted by Scorchin Scooter View Post
Yes I saw the diagram. Tahoedawgz said it can run that way only if the cart is switched pos at the key switch and switched neg at the vglide limit switch. How do you confirm that.?? He said most of the carts are switched positive. I only see 2 wires on the key switch blue and red , red positive and blue going to the micro switch on the foward and reverse switch.
If the one side is goes to the POS side of the Batteries then to the key switch it is switching POS
89GatorClub is offline   Reply With Quote
Unread 04-06-2012, 01:45 PM   #26
Not Yet Wild
 
Join Date: Feb 2012
Posts: 35
Default Re: Wiring a 25 amp voltage reducer

Hey gator got the reducer wired like the diagram you showed me lights still come on even when the key switch is off any clues off. I wired the reducer on the load side of the switch which has power when turned off. I tested both wires with switch on and off red wire blue wire. Blue wire with switch off had no power red did, turn on the switch both had power??????
Scorchin Scooter is offline   Reply With Quote
Unread 04-06-2012, 01:54 PM   #27
Gone Wild
 
89GatorClub's Avatar
Club Car
 
Join Date: Mar 2012
Location: Palatka, Fl
Posts: 799
Default Re: Wiring a 25 amp voltage reducer

Quote:
Originally Posted by Scorchin Scooter View Post
Hey gator got the reducer wired like the diagram you showed me lights still come on even when the key switch is off any clues off. I wired the reducer on the load side of the switch which has power when turned off. I tested both wires with switch on and off red wire blue wire. Blue wire with switch off had no power red did, turn on the switch both had power??????
The red wire(+36volt)from the reducer should hook where your blue wire does so that with the switch off there is no power to the reducer
89GatorClub is offline   Reply With Quote
Unread 04-06-2012, 05:29 PM   #28
Not Yet Wild
 
Join Date: Feb 2012
Posts: 35
Default Re: Wiring a 25 amp voltage reducer

Ok ill do that thanks
Scorchin Scooter is offline   Reply With Quote
Unread 04-06-2012, 10:58 PM   #29
Not Yet Wild
 
Join Date: Feb 2012
Posts: 35
Thumbs up Re: Wiring a 25 amp voltage reducer

Everything is working good!!!!!! Thanks
Scorchin Scooter is offline   Reply With Quote
Unread 04-07-2012, 06:02 AM   #30
Gone Wild
 
89GatorClub's Avatar
Club Car
 
Join Date: Mar 2012
Location: Palatka, Fl
Posts: 799
Default Re: Wiring a 25 amp voltage reducer

Quote:
Originally Posted by Scorchin Scooter View Post
Everything is working good!!!!!! Thanks
Grats
89GatorClub is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Voltage reducer wiring Electric Club Car
Voltage Reducer Wiring Electric EZGO
Wiring up a voltage reducer Electric Club Car
Voltage reducer wiring question Electric Club Car
Need Wiring diagram for new voltage reducer Electric Club Car


All times are GMT -5. The time now is 05:22 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.