|
05-01-2012, 04:29 PM
|
#1 |
|
Gone Wild
Join Date: Oct 2007
Location: Sebring,Florida
Posts: 160
|
OBC issue
I have service manual for 2007 prededent.Charger does not come on but works on another cart.Batteries are charged.I did all test procedures in service manual.Every test checks out ok.I bypassed the relay in charger and charger comes on.I think This tells me obc is bad.Can someone chime in on this?
Tom |
|
|
 Today
|
|
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
|
05-01-2012, 06:02 PM
|
#2 |
|
Medicare Recipient
 Join Date: Jun 2011
Location: West Michigan
Posts: 3,541
|
Re: OBC issue
. . . sounds good to me . . .
|
|
|
|
|
05-01-2012, 07:39 PM
|
#3 |
|
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: OBC issue
Does the cart run? If not, get it running by boosting the batteries with a conventional 12 volt battery charger.
If the car runs, check all connections on battery terminals for the wires. Especially the red wire from the charger receptacle. Tug on all the wires in the back of receptacle to make sure there's no internal breakage. Inspect the back of the OBC to make sure all connections are tight. If all this checks out fine, replace OBC. |
|
|
|
|
05-01-2012, 08:04 PM
|
#4 |
|
Gone Wild
Join Date: Oct 2007
Location: Sebring,Florida
Posts: 160
|
Re: OBC issue
Yes the cart runs,Checked all connections.I just can't find anything else.I've worked on to many of these.Tomorrow I'll put in a new obc and post results.
Tom |
|
|
|
|
05-01-2012, 09:20 PM
|
#5 |
|
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: OBC issue
It'll work
|
|
|
|
|
05-02-2012, 08:18 PM
|
#6 |
|
Gone Wild
Join Date: Oct 2007
Location: Sebring,Florida
Posts: 160
|
Re: OBC issue
Replaced obc today and all is fine.
Tom |
|
|
|
|
05-03-2012, 06:18 AM
|
#7 | |
|
Medicare Recipient
Join Date: Jun 2011
Location: West Michigan
Posts: 3,541
|
Re: OBC issue
Quote:
 |
|
|
|
|
 |
|
||||||
|
|
Similar Threads
|
||||
| Thread | Forum | |||
| G1 issue | Gas Yamaha | |||
| yet another issue | Electric EZGO | |||
| Charging Issue/ Battery Issue? | Electric EZGO | |||
| Still having a battery issue | Electric Club Car | |||
| g8 clutch issue | Gas Yamaha | |||
Linear Mode
