lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 06-08-2012, 08:37 PM   #1
JDC
Getting Wild
 
Join Date: Jun 2009
Location: Ontario Canada
Posts: 127
Default 05 pres wont go

I've checked the pack voltage it's at 50, key has power in and out , has keyed power to seliniod, changed the speed sencor and still wont go F or R backup buzzer works so I'd say the F/R switch is good. Is there a trouble shooting section here that I've missed. Is there a reed switch in the charge plug on these.
JDC is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 06-08-2012, 10:03 PM   #2
Not Yet Wild
 
Join Date: Jun 2010
Posts: 48
Default Re: 05 pres wont go

Possibly MCOR..just had to replace mine. If it sat for a couple days i had to keep the go pedal down for about 45 seconds before it would take off.
jonitza is offline   Reply With Quote
Unread 06-09-2012, 03:16 AM   #3
Gone Wild
 
Join Date: Dec 2010
Posts: 458
Default Re: 05 pres wont go

Quote:
Originally Posted by jonitza View Post
Possibly MCOR..just had to replace mine. If it sat for a couple days i had to keep the go pedal down for about 45 seconds before it would take off.
You can test the MCOR potentiometer as follows. Disconnect the batteries, unplug the 16 pin plug from the controller. Take a multimeter set to 20k ohms and insert the red probe to the plug pin 2 (yellow wire) and the black probe to plug pin 3 (purple wire). With the pedal at rest the reading should be +- 1k ohm, as you press the pedal to the floor the reading should increase to between 5.67k and 7.43k ohms.
Golfdog is offline   Reply With Quote
Unread 06-09-2012, 10:28 AM   #4
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: 05 pres wont go

Quote:
Originally Posted by JDC View Post
I've checked the pack voltage it's at 50, key has power in and out , has keyed power to seliniod, changed the speed sencor and still wont go F or R backup buzzer works so I'd say the F/R switch is good. Is there a trouble shooting section here that I've missed. Is there a reed switch in the charge plug on these.
does solenoid click when you hit pedal? no you don,t have a reed switch and just because reverse buzzer works dosn,t mean F&R is good......buzzer works off a microswitch..............if solenoid isn,t clicking you can try jumping it see if cart runs..........have you load tested batteries? only takes one to stop cart.......does charger still charge cart?.............................................
shadowman is offline   Reply With Quote
Unread 06-09-2012, 12:00 PM   #5
JDC
Getting Wild
 
Join Date: Jun 2009
Location: Ontario Canada
Posts: 127
Default Re: 05 pres wont go

The seliniod dos'nt click and I tried jumping it and still nothing checked voltage at seliniod and both large terminals have have voltage battery side is a little higher than the other. both small terminals have batt volts one turns off and on with the key. Is it normal for both to have voltage always. I have to check the pedal resistance yet.
JDC is offline   Reply With Quote
Unread 06-09-2012, 04:20 PM   #6
JDC
Getting Wild
 
Join Date: Jun 2009
Location: Ontario Canada
Posts: 127
Default Re: 05 pres wont go

Tested the MCOR and it was no good went and got another presto she's fixed. Thanks for the help. Now on to an electric ez-a-no-go.
JDC is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
07 CC Pres Lift Electric Club Car
Club Car 05 Pres Jake Lift Sway Lifted Golf Carts
Wont go Gas EZGO
Wont turn left and now wont turn right Electric EZGO
EZ-wont GO Gas EZGO


All times are GMT -5. The time now is 05:28 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.