lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 07-01-2012, 12:27 PM   #1
Not Yet Wild
 
Join Date: Jul 2012
Posts: 4
Default Club Car 25 Electric will not move

It was working one minute and not the next. All connections are clean and tight. The solenoid clicks, I jumped across the terminals to make sure it was good and nothing happened. I have 50 volts at the solenoid, both sides, and at the motor on all 4 terminals that I though was funny. How do I find the bad part on this thing?
morempgplus is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 07-01-2012, 12:49 PM   #2
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: Club Car 25 Electric will not move

what year? and voltage? ...................................
shadowman is offline   Reply With Quote
Unread 07-01-2012, 01:48 PM   #3
Not Yet Wild
 
Join Date: Jul 2008
Posts: 15
Default Re: Club Car 25 Electric will not move

I recently had the same symptom. It turned out the mcor was defective. There is a two wire plug that provides +48v through a switch in the mcor. I would advise you to disconnect the 2 pin connector and (with batteries disconnected, key off, in tow) jumper the connector pins together.

This is a simple quick test, and report back once you have tried it.
sternk13 is offline   Reply With Quote
Unread 07-02-2012, 08:07 AM   #4
Not Yet Wild
 
Join Date: Jul 2012
Posts: 4
Default Re: Club Car 25 Electric will not move

1998 48 volt
When I tested the solenoid with the load wire and resistor disconnected I had 14 volts measured on the terminal where I disconnected the load wire going to the controller and 50 volts when I closed the solenoid. I expected zero voltage on that terminal with the solenoid open. Do you think the solenoid is stuck closed?
morempgplus is offline   Reply With Quote
Unread 07-02-2012, 08:09 AM   #5
Not Yet Wild
 
Join Date: Jul 2012
Posts: 4
Default Re: Club Car 25 Electric will not move

Sorry, what is the mcor ?
morempgplus is offline   Reply With Quote
Unread 07-02-2012, 08:27 AM   #6
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: Club Car 25 Electric will not move

don,t worry about an m-cor a 98 dosn,t have one.......you either have a V-glide or pot box..............have you load tested all batteries? keep in mind just because they show voltage dosn,t mean one or more isn,t failing under load so you need to load test batteries...it only takes one battery to fail to stop cart dead..............is your F&R a lever or a rockerswitch?......if you jumped the large post on solenoid and it did nothing solenoid isn,t the problem if you didn,t jump the large post do that but 1st make sure batteries hold under load..................................
shadowman is offline   Reply With Quote
Unread 07-02-2012, 08:31 AM   #7
Gone Wild
 
camaroluvz28's Avatar
Yamaha
 
Join Date: Sep 2010
Location: Florida
Posts: 932
Default Re: Club Car 25 Electric will not move

MCOR = Motor Controller Output Regulator...basically tells the cart what speed to go as the pedal is pressed...also has microswitch inside that can prevent cart from running...but your solenoid wouldnt click if that microswitch was bad...however mcor unit itself may still be the problem
camaroluvz28 is offline   Reply With Quote
Unread 07-02-2012, 09:59 AM   #8
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: Club Car 25 Electric will not move

Quote:
Originally Posted by camaroluvz28 View Post
MCOR = Motor Controller Output Regulator...basically tells the cart what speed to go as the pedal is pressed...also has microswitch inside that can prevent cart from running...but your solenoid wouldnt click if that microswitch was bad...however mcor unit itself may still be the problem
a 1998 dosn,t have an m-cor..................................
shadowman is offline   Reply With Quote
Unread 07-02-2012, 10:04 AM   #9
Gone Wild
 
camaroluvz28's Avatar
Yamaha
 
Join Date: Sep 2010
Location: Florida
Posts: 932
Default Re: Club Car 25 Electric will not move

Ahhh indeed has a Contenuously Variable Potentiometer or V-Glide, my mistake :)
camaroluvz28 is offline   Reply With Quote
Unread 07-02-2012, 10:26 AM   #10
The Last Moja Morani
 
shadowman's Avatar
Club Car
 
Join Date: Jan 2007
Location: jumping from cart to cart
Posts: 8,975
Default Re: Club Car 25 Electric will not move

Quote:
Originally Posted by camaroluvz28 View Post
Ahhh indeed has a Contenuously Variable Potentiometer or V-Glide, my mistake :)
we all make them..................................
shadowman is offline   Reply With Quote
Reply

Tags
electrical problem
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
1997 club car electric will move a little Electric Club Car
Electric Club Car Won't Move Electric Club Car
86 electric club car wont move Electric Club Car
2003 Club Car Electric - clicks but will not move Electric Club Car
electric club car will not move Electric Club Car


All times are GMT -5. The time now is 08:23 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.