lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 07-12-2012, 11:48 AM   #1
suprsze007
Not Yet Wild
Club Car
 
Join Date: May 2012
Location: Canyon Lake, CA
Posts: 35
Unhappy Batteries Gone Wild

Let me start by saying I have a 2000.5 Club Car 48Volt Regen2 with an Alltrax DCX 500Amp controller and Interstate Workhorse batteries that are about 3+ years old. The problem started two days ago when i drove the cart for about 10 min. ride it started to shudder at high speed, the cart was slightly faster than normal so i figured something was definitely wrong. I got it back to the house and the motor was HOT, i could touch it and not burn my hand but it was a quick touch. I failed to get my temp meter out at the moment and temp it as it was getting late. So yesterday I scoured this site looking for answers. I'd narrowed it down to a possible voltage or pack issue. So i got home last night only to realize all the batteries were low on water and the pack was sitting at slightty over 67 volts....YES 67. So I ran to the store, got distilled water and filled all the batteries to spec. I let it sit over night and checked it this morning. Now the pack is sitting at 83 volts. I'm positive that's not good.....Question is, What do I do about it? I've figured out that the water was low and I put a full charge on the pack thus creating this issue.
suprsze007 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 07-12-2012, 12:02 PM   #2
scottyb
Happy Carting
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 73,356
Default Re: Batteries Gone Wild

I have never heard of this happening? Try changing the battery in your meter.
scottyb is offline   Reply With Quote
Old 07-12-2012, 12:30 PM   #3
suprsze007
Not Yet Wild
Club Car
 
Join Date: May 2012
Location: Canyon Lake, CA
Posts: 35
Default Re: Batteries Gone Wild

I will try that when I get home tonight. If it is over charged that high, any ideas? Last night when I metered them my 8Volt batteries were sitting at 11+ each. Thanks for your help Scottyb
suprsze007 is offline   Reply With Quote
Old 07-12-2012, 12:53 PM   #4
erict
Gone Wild
 
erict's Avatar
Club Car
 
Join Date: Sep 2011
Location: East Michigan
Posts: 1,364
Default Re: Batteries Gone Wild

Quote:
Originally Posted by scottyb View Post
I have never heard of this happening? Try changing the battery in your meter.
Or try a different meter all together....
erict is offline   Reply With Quote
Old 07-12-2012, 01:15 PM   #5
suprsze007
Not Yet Wild
Club Car
 
Join Date: May 2012
Location: Canyon Lake, CA
Posts: 35
Default Re: Batteries Gone Wild

I think i'm going to head over and buy a new one this morning just to avoid any and all confusion later this afternoon. Hopefully that fixes the issue.
suprsze007 is offline   Reply With Quote
Old 07-12-2012, 03:22 PM   #6
scottyb
Happy Carting
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 73,356
Default Re: Batteries Gone Wild

I have a few meters, 2 are good Fluke meters. They will confuse the hell out of a technician when the battery gets low.... which it does because I'm constantly leaving them on and walking away ...
scottyb is offline   Reply With Quote
Old 07-12-2012, 07:31 PM   #7
suprsze007
Not Yet Wild
Club Car
 
Join Date: May 2012
Location: Canyon Lake, CA
Posts: 35
Default Re: Batteries Gone Wild

So I just got home with my new meter am tested the pack again....... 49.7V and each battery is around 8.3 or so. Thats after about a 12 mile ride up and down some pretty decent hills loade with 4 people. So let's now move on to what might have brought on the high speed shutter and HOT motor. Any ideas? Let me throw this in there too. At half throttle it shudders the same way all the time as it did this one time at high speed. Normally I can cruise slow, then half throttle it shudders if I hold it there, then it's perfect on full throttle. But that one time it did it at full throttle too.
suprsze007 is offline   Reply With Quote
Old 07-12-2012, 10:15 PM   #8
scottyb
Happy Carting
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 73,356
Default Re: Batteries Gone Wild

what solenoid do you have?
scottyb is offline   Reply With Quote
Old 07-12-2012, 10:47 PM   #9
suprsze007
Not Yet Wild
Club Car
 
Join Date: May 2012
Location: Canyon Lake, CA
Posts: 35
Default Re: Batteries Gone Wild

It's 400 continuous 1000 peak heavy duty.
suprsze007 is offline   Reply With Quote
Old 07-12-2012, 10:54 PM   #10
suprsze007
Not Yet Wild
Club Car
 
Join Date: May 2012
Location: Canyon Lake, CA
Posts: 35
Default Re: Batteries Gone Wild

I'm charging the batteries now to see what happens on a full charge. I have a theory.

I'm also running all #2 gauge wires to all batteries and motor.

The batteries were low on water and I charged the pack. The charger shut off giving me the assumption it was fully charged when in reality the batteries were probably low. I drove the cart thus dropping the voltage even further producing the shuddering, since the controller and motor were starving for volts the motor got HOT. Having a broken meter I was unable to check what voltage was. So when I filled the batteries with water and let them sit it brought them up to 49 volts which is not a full charge. When I drove it tonight I shuddered slightly at high speed but the pack was only at 49 volts. Sound logical?
suprsze007 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes



All times are GMT -5. The time now is 05:18 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.