lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 09-11-2012, 10:25 AM   #1
Not Yet Wild
Club Car
 
Join Date: Feb 2009
Location: League City, TX.
Posts: 57
Default Precedent Motor Stall

Hi,
I've never had this problem before so I'm a little stumped! I have a 2007 club car precedent, full battery pack voltage, solenoid clicks but I keep getting a motor stall fault. The service manual says something stupid like "tell the customer not to stall the motor", which is not very helpful! All wiring looks intact, going to try jumpering the solenoid this am but wondered if anyone has any other thoughts? Thanks in advance!
ckdgolfcarts is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 09-11-2012, 10:25 PM   #2
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,960
Default Re: Precedent Motor Stall

Is the motor stall code happening while you drive it? Or is it in the fault history? Low voltage can cause it. Just because it's got plenty of power now doesn't mean it's not been low in the past. If it has, "LOW BATTERY VOLTAGE" should also be in the fault history. If so, I'd blame it on that. Otherwise I'd be tearing the motor apart to inspect the brushes and check everything else out while I'm in there. You could have a burnt spot on the armature. Also, check to make sure the brakes aren't dragging. If the IQ controller senses too much of a load it will automatically stall the motor to prevent overload and excess heat.
TahoeDawgZ71 is offline   Reply With Quote
Unread 09-12-2012, 12:54 AM   #3
Not Yet Wild
Club Car
 
Join Date: Feb 2009
Location: League City, TX.
Posts: 57
Default Re: Precedent Motor Stall

Hi Tahoe Dawg,
Thanks for the reply! I appreciate it! I did Change to motor out originally due to the motor stall fault code but it didn't make any difference. When I looked a little closer, I was also getting a "missing field" fault code along with the motor stall code. One of the fixes was to replace the controller and once I did that, everything came back to life! Thanks again for the advice!
ckdgolfcarts is offline   Reply With Quote
Unread 09-12-2012, 01:27 PM   #4
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,960
Default Re: Precedent Motor Stall

Oh yeah... missing field is a common controller failure code
TahoeDawgZ71 is offline   Reply With Quote
Unread 09-30-2013, 04:54 AM   #5
Not Yet Wild
Club Car
 
Join Date: Apr 2010
Location: Port Charlotte, Florida
Posts: 6
Default Re: Precedent Motor Stall

I have a similar problem, Cart was completly dead, even the Programmer would not light up when pluged in, replaced controller, programmer came to life, cart would move forward but not in reverse and gave a missing field fault, if I understand this correctly it's telling me one of my fields in the motor may be shot or possibly the F1/F2 wires are bad which took out the controller. Soooo...I dropped in another motor and same fault code comes up... could the old motor have taken out the new controller? Or am missing something here?
DGCarts is offline   Reply With Quote
Unread 09-30-2013, 09:55 PM   #6
Not Yet Wild
Club Car
 
Join Date: Feb 2009
Location: League City, TX.
Posts: 57
Default Re: Precedent Motor Stall

Did you happen to check continuity on the field wires?
ckdgolfcarts is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
G16a Hard Start and Stall Gas Yamaha
1986 club car stall Gas Club Car
Cart Problems: Speed Sensor & Motor Stall Electric Club Car
G16 Surge-Stall-Surge-Stall... FIXED Gas Yamaha
complete stall going up hill Electric EZGO


All times are GMT -5. The time now is 07:59 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.