lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 11-01-2012, 08:26 PM   #1
Not Yet Wild
 
Join Date: Nov 2012
Location: Va
Posts: 3
Default 2007 Club Car Precedent 48 volt

Fault light comes on when you let off accelerator . Cart runs good other than the light coming on.
Brenda is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 11-02-2012, 01:14 PM   #2
Gone Wild
 
Join Date: Nov 2011
Posts: 165
Default Re: 2007 Club Car Precedent 48 volt

By fault light do you mean the amber battery light?
LJ12530 is offline   Reply With Quote
Unread 11-03-2012, 09:01 AM   #3
Not Yet Wild
 
Join Date: Nov 2012
Location: Va
Posts: 3
Default Re: 2007 Club Car Precedent 48 volt

Yes, yellow light on dash
Brenda is offline   Reply With Quote
Unread 11-03-2012, 06:07 PM   #4
Gone Wild
 
Join Date: Nov 2011
Posts: 165
Default Re: 2007 Club Car Precedent 48 volt

The amber light comes on when the computer thinks that you have 25% of your battery capacity remaining. It is just a "warning" light and does not indicate any type of failure. The computer estimates the remaining capacity by knowing the voltage and using a rough assumption that a fully charged 48V battery system will measure about 51 volts and one down to 25% will measure about 47 volts. Assuming the light is working properly it means that your batteries are dropping down to 47 volts. When you take the load off the batteries the voltage will recover a bit and will go back above 47 volts, and the light will go off.

If your batteries are 4 years old or so or have seen a lot of charge/discharge cycles I suspect the batteries are nearing the end of their life.

There are 2 ways to determine their health. One is to measure the specific gravity of each cell and see if they are all where they should be. Another way is to just get in the cart, put the pedal to the metal, and see how long they last ( a load test ). This is the most foolproof way to test batteries. Believe it or not, healthy batteries should allow you to go full throttle ( assuming no mods that would be 19.6 mph ) for about 90 minutes before the amber light comes on steady.
LJ12530 is offline   Reply With Quote
Unread 11-04-2012, 06:44 PM   #5
Not Yet Wild
 
Join Date: Nov 2012
Location: Va
Posts: 3
Default Re: 2007 Club Car Precedent 48 volt

Thanks for your help.
Brenda is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
2007 Club Car Precedent Electric Club Car
converting 2007 precedent to 8 volt batteries Electric Club Car
2007 48 volt club car not working Electric Club Car
2007 Club Car Precedent Golf Carts and Parts


All times are GMT -5. The time now is 03:31 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.