|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
11-27-2012, 11:39 AM | #1 |
The Fabricator
Join Date: Dec 2006
Posts: 2,016
|
02 DS IQ Cutting Out at Full Speed Going Down a Hill
I have a 02 Club Car 48 volt with new batteries. It will be running full throttle and then cuts out and starts beeping. I repress the throttle and it will start running again until a few minutes later the same thing happens again. Ive noticed this occuring going down hills.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
11-27-2012, 01:02 PM | #2 | |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: 02 DS IQ Cutting Out at Full Speed Going Down a Hill
Quote:
Someone should come along and confirm or deny this |
|
11-27-2012, 01:46 PM | #3 |
The Fabricator
Join Date: Dec 2006
Posts: 2,016
|
Re: 02 DS IQ Cutting Out at Full Speed Going Down a Hill
I did the speed sensor test but it worked. While the speed sensor is starting to go bad could it still pass the test?
|
11-27-2012, 10:10 PM | #4 |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: 02 DS IQ Cutting Out at Full Speed Going Down a Hill
I guess it could still pass...
It may be your F&R switch because when you are driving forward and flip the switch to reverse or neutral, it will stop the cart and make a beeping noise until it stops completely. Maybe try that while you are driving to check that feature. |
11-29-2012, 09:39 PM | #5 |
The Fabricator
Join Date: Dec 2006
Posts: 2,016
|
Re: 02 DS IQ Cutting Out at Full Speed Going Down a Hill
It acts like the power is shut off. Only happened so far going down hills at full throttle. Hasnt started doing this until just recently.
|
11-29-2012, 11:04 PM | #6 | |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: 02 DS IQ Cutting Out at Full Speed Going Down a Hill
Quote:
A. Not moving when you change directions with FR switch B. Not moving after you come to a complete stop without pressing the accelerator (run away) If a or b happens, the cart will stop and emit a beep beep until it is stopped. For some reason it seems like your cart thinks the FR switch has been flipped for a split second. That is why I am leaning towards the speed sensor. |
|
11-30-2012, 06:18 AM | #7 |
Medicare Recipient
Join Date: Jun 2011
Location: West Michigan
Posts: 3,541
|
Re: 02 DS IQ Cutting Out at Full Speed Going Down a Hill
. . . if all else seems normal with cart and the only time it slows down is going down a hill with foot off of GO pedal, I think everything is normal . . . from the CC Manual"
"• Pedal Up Motor Braking: When vehicle speed is above 11 mph (17.7 km/h), releasing the accelerator pedal will activate motor braking, which slows the vehicle speed. Once vehicle speed slows to below approximately 11 mph (17.7 km/h), with the accelerator pedal still released, motor braking will be deactivated and the vehicle will coast freely. This feature is selectable. Contact your Club Car dealer/distributor to inquire about this selectable feature" . . . |
12-06-2012, 10:56 PM | #8 | |
The Fabricator
Join Date: Dec 2006
Posts: 2,016
|
Re: 02 DS IQ Cutting Out at Full Speed Going Down a Hill
Quote:
|
|
12-07-2012, 12:02 AM | #9 |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: 02 DS IQ Cutting Out at Full Speed Going Down a Hill
That is definitely not normal behavior- there is definitely a problem. Since the speed sensor test passed, it is beyond me...
|
12-07-2012, 09:43 AM | #10 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: 02 DS IQ Cutting Out at Full Speed Going Down a Hill
102355201 - Main Dropout Harness - IQ.... Order one of these... Lots of early IQ cars would dropout for no apparent reason. This will correct it. It's a simple inline diode that snaps in behind the tow/run switch.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Par car cutting out | Gas Columbia ParCar | |||
G16 cutting out HELP ME ! | Gas Yamaha | |||
Cutting out | Gas Club Car | |||
G16 cutting off | Gas Yamaha | |||
97 G16 Cutting out at WOT | Gas Yamaha |