lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars

Post New Thread  Reply
Thread Tools Display Modes
Unread 03-20-2013, 09:57 AM   #1
Not Yet Wild
Join Date: Jan 2013
Posts: 33
Default Thank for all your help one more question...Batteries

Hey guys thanks for everything one more question. If I bypass the OBC will the charger charge the pack even though the batteries are low low. The pack is dead, I tried to charge this past month with a 6amp secondary charger I use for four wheelers when needed. I couldn't use the cart charger due to the precharge resistor being out and the cheap charger obviously couldn't handle charging the batteries. I think the secondary charger has a faulty shutoff or something, it says charged but the voltage on the batteries is low like 4 or 5 volts. The batteries were only a year old and weren't fully charged when my son topped them off with water, then the controller went out. So bottom line is they've been dead for over a month and and the secondary charger obviously didn't do it's job.

So now I need to get the batteries up to snuff and I think they're to low for the cart charger to kick on, so if I bypass the obc will the charger kick on even though there super low or do I need to get another secondary charger and attempt to get charged to get the cart charger going?? Thanks again you guys are great.
hawgsalot is offline   Reply With Quote
Alt Today

Golf car forum Sponsored Links

This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
Unread 03-20-2013, 10:24 AM   #2
Happy All Hallow's Eve
scottyb's Avatar
Join Date: Dec 2007
Location: Southern California
Posts: 59,505
Default Re: Thank for all your help one more question...Batteries

The OBC bypass should jumpstart the charging. Let it run like this for 3-45 minutes or until the pack reads about 48V under charge. Disconnect the charger, remove the bypass, and reconnect the charger, if the pack voltage is high enough (+ or - 44v at rest) the charger should recognize the pack and continue until it shuts off on it's own.
scottyb is online now   Reply With Quote
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car

Thread Tools
Display Modes

Similar Threads
Thread Forum
12V Batteries vs 6V Question Electric EZGO
batteries question Electric EZGO
Question about batteries Electric Yamaha
New Batteries Question Electric Club Car
New batteries/ question Electric EZGO

All times are GMT -5. The time now is 02:42 PM.

Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2016, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.