|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
03-27-2013, 11:16 AM | #1 |
Gone Wild
Join Date: Jan 2011
Location: mascoutah,il
Posts: 386
|
Power drive 2 problem
I HAVE A 2005 CLUB CAR WITH A POWER WISE 2 CHARGER. THE CHARGER WILL POP THE CIRCUIT BREAKER SECONDS AFTER BEING HOOKED TO THE CAR. I SUSPECT THE CONTROLLER IS SHORTED BUT DO NOT HAVE A DIAGNOSTIC CHART TO TEST. CAN ANYONE HELP PLEASE?
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
03-27-2013, 11:31 AM | #2 | |
Gone Wild
Join Date: Aug 2009
Posts: 14,245
|
Re: Power drive 2 problem
Quote:
Also, I assume you mean Powerdrive, not Powerwise??? Powerwise is EZGO |
|
03-27-2013, 01:08 PM | #3 |
Gone Wild
Join Date: Jan 2011
Location: mascoutah,il
Posts: 386
|
Re: Power drive 2 problem
This cart belongs to the high school and is abused. Been run until dead several times. Towed and maybe the tow/run switch not switched to tow? When i check the neg. Wire that runs to the controller it is dead? Power drive is correct,sorry i am an ezgo owner.
|
03-27-2013, 01:14 PM | #4 |
Getting Wild
Join Date: Mar 2013
Location: Southern Illinois
Posts: 94
|
Re: Power drive 2 problem
Busman if you determine the controller is bad I have one in the shed I might consider selling? I live about 30 miles from you.
|
03-27-2013, 01:28 PM | #5 |
Gone Wild
Join Date: Jan 2011
Location: mascoutah,il
Posts: 386
|
Re: Power drive 2 problem
I might be interested. Does anyone have a diagnostic chart like ezgo side has to check the controller?
|
03-27-2013, 02:08 PM | #6 |
Gone Wild
Join Date: Jan 2011
Location: mascoutah,il
Posts: 386
|
Re: Power drive 2 problem
I went through the obc reset and no rev beep ???????????
|
03-27-2013, 02:16 PM | #7 |
Gone Wild
Join Date: Dec 2009
Location: Aiken, SC
Posts: 13,131
|
Re: Power drive 2 problem
I'm thinking its the rectifier or the circuit breaker in the charger.. If it was a short in the cart bad other things would be happening.. Here is a link to a fix all kit for the charger.. http://www.ebay.com/itm/Club-Car-48-...95d507&vxp=mtr
|
03-27-2013, 02:27 PM | #8 |
revolutiongolfcars.com
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
|
Re: Power drive 2 problem
It sounds to me as if you need to fix the charger first and foremost without a doubt. It also sounds like your car has discharged too low from sitting with no charge.
|
03-27-2013, 02:33 PM | #9 |
Gone Wild
Join Date: Jan 2011
Location: mascoutah,il
Posts: 386
|
Re: Power drive 2 problem
Just installed new batteries,pack voltage 50.2 the cart will move but when the charger is plugged in it starts for 15 sec and then the charger circuit breaker pops. Why can i not get the rev beeper to sound when resetting obc?
|
03-27-2013, 07:31 PM | #10 |
Getting Wild
Join Date: Mar 2013
Location: Southern Illinois
Posts: 94
|
Re: Power drive 2 problem
Just a question since the cart belongs to the high school has the kids un-hooked the annoying buzzer? if not I would think your OBC may be shot.
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
power drive charger | Electric EZGO | |||
Power Drive 3 Charger Problem | Electric Club Car | |||
Power Drive System 48v | Electric Club Car | |||
power drive charger | Electric Club Car | |||
Power Drive VS I Q Plus | Electric Club Car |