lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 03-28-2013, 07:15 PM   #1
Getting Wild
 
orions empire's Avatar
Club Car
 
Join Date: Aug 2010
Location: PR
Posts: 105
Default Help!!! Click, no go, new batt '96, 48v

Hi guys, lomg time...

I placed two years ago new solenoid, altrax controller and last year new obc.

6 months ago batteries went bad, I waited until last week to purchase the full 8v pack.

Installed, charged them, 50.1volts from full pack, click on the solenoid, but it wont move....

I jumped the two poles from the solenoid, v swith to fwd, and pressed pedal, still hear the click, but it wont move at all. (Btw, cart was on towers, in case it move, it would ran me over ;) )

Any suggestions.
orions empire is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 03-28-2013, 07:20 PM   #2
Cartsunlimited.net
 
scottyb's Avatar
E-Z-GO
 
Join Date: Dec 2007
Location: Southern California
Posts: 64,088
Default Re: Help!!! Click, no go, new batt '96, 48v

96 series cart, solenoid clicks, 50v, no go.... maybe the F&R contacts are bad or a cable connection is bad? Are you getting a solid green light on the control when you try to go? If not, then what color & count of blinking lights?
scottyb is offline   Reply With Quote
Unread 03-28-2013, 09:41 PM   #3
Getting Wild
 
orions empire's Avatar
Club Car
 
Join Date: Aug 2010
Location: PR
Posts: 105
Default Re: Help!!! Click, no go, new batt '96, 48v

Hey Scottyb, thank you for fast reply.

Controller is blinking 7 times in fwd and 7 times in reverse.

Green led
orions empire is offline   Reply With Quote
Unread 03-28-2013, 09:44 PM   #4
Getting Wild
 
orions empire's Avatar
Club Car
 
Join Date: Aug 2010
Location: PR
Posts: 105
Default Re: Help!!! Click, no go, new batt '96, 48v

LED Status Indicator:
and used for troubleshooting.

The LED Blink Codes occur at power up, the number of green blinks indicates
the throttle configuration: *
1 Green LED flash ***= 0-5 kohm resistive
2 Green LED flashes = 5K-0 ohm resisitive
3 Green LED flashes = 0-5 Volt
4 Green LED flashes = EZ-GO inductive (ITS)
5 Green LED flashes = Yamaha 0-1K ohm resistive
6 Green LED flashes = Taylor-Dunn 6-10.5 Volt
7 Green LED flashes = ClubCar 5k-0 ohms, 3-wire throttle

Normal display status: *****
Solid Green: Controller ready to run
Solid Red: Controller in programming mode (using Controller Pro)
Solid Yellow: *Controller throttle is wide open, controller is supplying
max output, and is not in current limit.

Trouble Shooting:
Error code display:# of RED blinks ***indicates any error conditions that might
exist:

1 Red *= *Throttle Position Sensor Over Range. *Check for open wires.
2 Red *= *Under Temperature. *Controller below -25C
3 Red *= *HPD. *Throttle hasn't gone to zero during this power on cycle.
4 Red *= *Over Temperature. *Controller over 95C
5 Red *= *Not used
6 Red *= *Battery Under Voltage detected. *Battery V < under voltage slider
7 Red *= *Battery Over Voltage detected. *Battery V > over voltage slider
orions empire is offline   Reply With Quote
Unread 03-28-2013, 09:45 PM   #5
Getting Wild
 
orions empire's Avatar
Club Car
 
Join Date: Aug 2010
Location: PR
Posts: 105
Default Re: Help!!! Click, no go, new batt '96, 48v

What does it means:

7 Green LED flashes = ClubCar 5k-0 ohms, 3-wire throttle
orions empire is offline   Reply With Quote
Unread 03-28-2013, 10:30 PM   #6
Getting Wild
 
orions empire's Avatar
Club Car
 
Join Date: Aug 2010
Location: PR
Posts: 105
Default Re: Help!!! Click, no go, new batt '96, 48v

Note: just curious, after the blinking, led shuts off, even if the pedal still pressed.
orions empire is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
RXV 2009 click click but won't move Electric EZGO
No click, click, when I hook up my charger? Electric Club Car
Number of batt. Electric Club Car
Click Click - will not move ! Electric EZGO
12v batt question Electric EZGO


All times are GMT -5. The time now is 06:33 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.