lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 06-24-2013, 11:00 PM   #1
Not Yet Wild
 
Join Date: Jun 2013
Posts: 3
Default 06 Club Car moves 4' forward and stops

Just brought this 48v car a few months ago and ran fine, ran it down a long hill and another 1/4 mile and stopped for 10 minutes. Tried to move and it only went 2' and stopped, same in reverse,2' and stopped. Tried a few more times and would not move at all. Towed back and put on charge after 12 hours tried again and it moved 5' in both directions and stopped. Jacked up and motor did not lock, only one wheel turned, held it and the other engaged. Put back on ground and 5' both directions. While watching the motor just before it stops the motor torques in the direction going and then the car stops almost like putting an emergency brake on.

Thanks for any suggestions
Kevin
Gonecarting is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 06-28-2013, 12:25 AM   #2
Member #16,745
 
jakesnake27's Avatar
Harley Davidson
 
Join Date: Aug 2009
Location: Missouri
Posts: 9,895
Default Re: 06 Club Car moves 4' forward and stops

How old are the batts?
Welcome to BGW!
jakesnake27 is offline   Reply With Quote
Unread 06-30-2013, 06:44 PM   #3
Not Yet Wild
 
Join Date: Jun 2013
Posts: 3
Default Re: 06 Club Car moves 4' forward and stops

Batteries are in good shape only a year old, all read 13+ volts when charged and 50v connected. A follow up to my post, I removed the motor to see if there was any binding in it or the diff. Both spun freely and no noise. I put back together and tried again and to be more specific the cart goes the second the accelerator is depressed but after 5' it is as if i took my foot off the pedal and the cart stops. Depress the pedal and it moves 2' and stops, then it will not move even though the motor engages . Same occurs in reverse.

Thanks for the welcome.

Kevin
Gonecarting is offline   Reply With Quote
Unread 06-30-2013, 11:57 PM   #4
Member #16,745
 
jakesnake27's Avatar
Harley Davidson
 
Join Date: Aug 2009
Location: Missouri
Posts: 9,895
Default Re: 06 Club Car moves 4' forward and stops

I would do a speed sensor test. (Look in above stickies)
If that's not it, the MCOR could've gone bad...
jakesnake27 is offline   Reply With Quote
Unread 07-02-2013, 07:47 AM   #5
Not Yet Wild
 
Join Date: Jun 2013
Posts: 3
Default Re: 06 Club Car moves 4' forward and stops

Speed sensor test checks out fine, back up alarm comes on both forward and reverse. Is the MCOR the black box mounted behind the batteries? I am not familiar with cart terminology but could this problem be associated with something connected to the accelerator? It acts almost like a bad rheostat that is shorted, as it is turned the voltage increases until it comes to the short and disconnects the power, signal. The cart is acting the same way moves as soon as you engage the accelerator and then stops when full or 5', what's puzzling is after two tries you can see the motor twist but won't move the cart. If it is the MCOR is there somewhere I can send it to be troubleshooted and repaired or is this a throw away and buy new, can I assume this is a pricey component?
Gonecarting is offline   Reply With Quote
Unread 07-02-2013, 09:17 AM   #6
Gone Wild
 
Join Date: Jul 2012
Posts: 912
Default Re: 06 Club Car moves 4' forward and stops

Mcor is under the pedal assembly, it is a little black box that controls throttle output. They are around $150 and if its bad it is a throw away part.
Speedchaser is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
48 volt moves an inch then stops Electric Club Car
Electric Club Car Clicks, and moves for a split second, then stops Electric Club Car
Club Car DS 2002 Lurches forward, then Stops Electric Club Car
Cart moves forward without pressing the accelerator Electric Club Car
moves 5 ft and stops Electric EZGO


All times are GMT -5. The time now is 01:13 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.