lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 07-28-2013, 11:55 AM   #11
Not Yet Wild
 
Join Date: Jul 2013
Posts: 9
Default Re: Club car reverse beeping alarm in forward & neutral too. Cart won't move.

Yes, I removed all three from the F&R switch. I jumped the orange & brown one, leaving the blue one alone. I put one wire in the brown & as soon as I put the wire in the orange one, it started buzzing. When I removed the wire i was using to jump the orange/brown wires, the buzzing stopped. I pushed the accelerator down(while I was jumping the orange/brown wires), but cart didn't move.
Mom3kids is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 07-28-2013, 12:01 PM   #12
Not Yet Wild
 
Join Date: Jul 2013
Posts: 9
Default Re: Club car reverse beeping alarm in forward & neutral too. Cart won't move.

I used a small wire to jump the orange/brown ones. I placed one end of the wire in the brown & the other end in the orange. It was when I put the other end into the orange, that the reverse alarm started buzzing right away. I hope that clarifies what I did. Thanks again!
Mom3kids is offline   Reply With Quote
Unread 07-29-2013, 09:22 AM   #13
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,989
Default Re: Club car reverse beeping alarm in forward & neutral too. Cart won't move.

By doing this test you're basically eliminating the possibility of a short in the F&R switch. I was thinking that maybe there was an internal short in the switch that was making the car think it was in Forward AND Reverse at the same time. When this happens, the cart won't run. This test confirms that the cart beeps no matter what position the selector is in. My diagnosis is a bad controller.
TahoeDawgZ71 is offline   Reply With Quote
Unread 07-29-2013, 10:03 AM   #14
Not Yet Wild
 
Join Date: Jul 2013
Posts: 9
Default Re: Club car reverse beeping alarm in forward & neutral too. Cart won't move.

Great, we will get a controller. One last question, if we noticed in the past few weeks, when cart was working, that our cart speed was much slower than usual, would that of been due to controller going out or could there be another problem with our OBC?

Thank you so much for everything!
Mom3kids is offline   Reply With Quote
Unread 07-29-2013, 03:03 PM   #15
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,989
Default Re: Club car reverse beeping alarm in forward & neutral too. Cart won't move.

Quote:
Originally Posted by Mom3kids View Post
Great, we will get a controller. One last question, if we noticed in the past few weeks, when cart was working, that our cart speed was much slower than usual, would that of been due to controller going out or could there be another problem with our OBC?

Thank you so much for everything!
Could be a sign of a bad speed sensor, bad controller, bad MCOR, or low battery voltage. Without some voltage numbers or throttle readings I can't tell you for sure. It's definitely not an OBC problem.
TahoeDawgZ71 is offline   Reply With Quote
Unread 09-01-2014, 04:22 PM   #16
Gone Wild
Club Car
 
Join Date: Dec 2013
Location: Connecticut
Posts: 240
Default Re: Club car reverse beeping alarm in forward & neutral too. Cart won't move.

Don't want to hijack this thread...just a quick shout out and "thank you" to TahoeDawgZ71 for his expert advice...

Had a similar problem and found this thread...pulled all three wires and jumped the brown and orange...car went forward...!!! Took the rocker switch apart and it was full of corrosion. Cleaned and reassembled it, lubed it with dielectric grease...worked like a charm...!!!

Thanks sooooo much for the great advice...keep up the good work...!!!
flkeysdude359 is offline   Reply With Quote
Unread 09-01-2014, 06:40 PM   #17
Dawg Gone Wild
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 7,989
Default Re: Club car reverse beeping alarm in forward & neutral too. Cart won't move.

Quote:
Originally Posted by flkeysdude359 View Post
Don't want to hijack this thread...just a quick shout out and "thank you" to TahoeDawgZ71 for his expert advice...

Had a similar problem and found this thread...pulled all three wires and jumped the brown and orange...car went forward...!!! Took the rocker switch apart and it was full of corrosion. Cleaned and reassembled it, lubed it with dielectric grease...worked like a charm...!!!

Thanks sooooo much for the great advice...keep up the good work...!!!
You're very welcome.
TahoeDawgZ71 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Forward Neutral Reverse Transmission Gear Box Go Cart Lifted Golf Carts
94 Club Car Alarm Sounds in Forward and Reverse Electric Club Car
Reverse alarm sounds in Forward, wont go forward or reverse Electric Club Car
Alarm sounding in forward. No movement in forward or reverse Electric Club Car
Forward Neutral Reverse Switch Gas Club Car


All times are GMT -5. The time now is 07:20 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.