lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 08-25-2013, 12:00 PM   #1
Not Yet Wild
 
Join Date: Feb 2012
Location: Missouri
Posts: 17
Default Need a little advice !

98 club wont charge, researched and found were you can jumper couple wires to check in see if its the charger or OBC but unsure of exactly which two wires ?
There is a blue,red, white (insulated from TF) and black coming from 15 amp reset.
I will try and get a photo uploaded in the meantime. Thanks
I wanna assume I jump the black and red ?
Thanks for the help !
Tnhunter is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 08-25-2013, 12:18 PM   #2
Gone Wild
 
Storm S's Avatar
Club Car
 
Join Date: Aug 2013
Location: PBG, Florida
Posts: 247
Default Re: Need a little advice !

Above the breaker is a relay with 4 wires. Top two are trigger. Ignore them. Other two are ac voltage in and out. Jump those two together.
Storm S is offline   Reply With Quote
Unread 08-25-2013, 07:38 PM   #3
Member #16,745
 
jakesnake27's Avatar
Harley Davidson
 
Join Date: Aug 2009
Location: Missouri
Posts: 9,883
Default Re: Need a little advice !

You do have a 48v cart with a Powerdrive charger right?
If it charges once you jump the relay, you more than likely have a bad OBC.
Be sure to watch the ammeter and monitor pack voltage while charging with the relay jumped, because the charger will never shut off and can cook the batts.
jakesnake27 is offline   Reply With Quote
Unread 08-25-2013, 09:23 PM   #4
Not Yet Wild
 
Join Date: Feb 2012
Location: Missouri
Posts: 17
Default Re: Need a little advice !

Thanks for input ! After further searching I think my pack is to low to initiate a charge. My dad has not charged the batts and let them run completely down......I have seperated the batteries and charging them individually with a 6 volt charger and then will tie them back together and try again.
Each battery only tested out at 2.3 +/- volts. I hope he has not ruined my batteries !!
I store my cart there as I live in a different state and hunt there primarily.
My cart is a 98 CC 48volt with the imaginative manufacturing 4x4 kit installed.
Tnhunter is offline   Reply With Quote
Unread 08-25-2013, 09:31 PM   #5
Gone Wild
 
Storm S's Avatar
Club Car
 
Join Date: Aug 2013
Location: PBG, Florida
Posts: 247
Default Re: Need a little advice !

My batts were crazy low when I bought my cart. If you leave the pack wired together and bypass the charger it will bring all of them up in voltage at the same time. Much easier that way. I did mine for about 4 hours and then took the bypass off.
Storm S is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
At it again, need some advice Body and Paint
Looking for advice on a 92 ez go? Gas EZGO
looking for some advice Body and Paint
Need Advice Gas Harley Davidson
Need advice Electric EZGO


All times are GMT -5. The time now is 11:54 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.