lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
 
Thread Tools Display Modes
Old 09-25-2013, 04:06 PM   #1
Toolman67
Not Yet Wild
Club Car
 
Join Date: Sep 2013
Posts: 7
Default Did a reset on the OBC & now cart does not move

Just did a reset on the obc and now the cart does not move, 95 Club Car DS 48v, was able to move before the reset, when the pedal is pressed it wants to try in either forward or reverse, the total volts are up to 47.63, all new batteries and new club car charger, here a click under the pedal
Toolman67 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Old 09-25-2013, 04:25 PM   #2
crash test dummy
Guest
 
Posts: n/a
Default Re: Did a reset on the OBC & now cart does not move

Quote:
total volts are up to 47.63
thats way to low !!! you need to fully charge new batteries before you run cart
  Reply With Quote
Old 09-25-2013, 05:17 PM   #3
jakesnake27
Gone Wild
 
Join Date: Aug 2009
Posts: 14,245
Default Re: Did a reset on the OBC & now cart does not move

Yeah for sure, the cart definitely won't run with that voltage...
You need to charge them ASAP, because they are being ruined right now!
jakesnake27 is offline   Reply With Quote
Old 09-25-2013, 05:30 PM   #4
crash test dummy
Guest
 
Posts: n/a
Default Re: Did a reset on the OBC & now cart does not move

as we said before in your other post
Quote:
Originally Posted by crash test dummy View Post
you could by pass the obc to get the pack up



to by pass OCB
DO AT YOUR OWN RISK.…do not attempt unless you are familiar with electricity and electronics!
There are two ways to force the charger to turn on regardless of the OBC.

The first method is to disconnect the cart’s gray wire at the fuse near the charger receptacle. Then using a jumper wire, connect the receptacle side of the fused connector to the cart’s negative battery terminal. This will energize the charger’s 48V relay. If the charger doesn’t come on, it could be bad connections, wiring or charger relay.

The second method is to open the charger and remove the 120V wires from the relay and jump these together. This totally bypasses the relay and the OBC wire.


(If charger comes on but the charger ammeter shows 0 amps, check the fuse at the charging receptacle under the clear plastic cover.)

Both of these methods should both be temporary measures for troubleshooting, or as an emergency method of charging the batteries when they have been discharged so far that the OBC will not charge them.

The OBC provides the optimum method of charging the cart’s batteries. If the OBC is bad, it should be replaced
  Reply With Quote
Old 09-25-2013, 07:32 PM   #5
Anselmo
Not Yet Wild
 
Join Date: Sep 2013
Posts: 2
Default Re: Did a reset on the OBC & now cart does not move

my volt is 49.51 and the charger kicks on and then kicks off, is this normal?
Anselmo is offline   Reply With Quote
Old 09-25-2013, 07:35 PM   #6
TahoeDawgZ71
revolutiongolfcars.com
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
Default Re: Did a reset on the OBC & now cart does not move

Quote:
Originally Posted by Anselmo View Post
my volt is 49.51 and the charger kicks on and then kicks off, is this normal?
Kicking on is normal. Kicking off is normal too after it's finished charging. How long does it take to kick off?
TahoeDawgZ71 is offline   Reply With Quote
Old 09-25-2013, 07:47 PM   #7
crash test dummy
Guest
 
Posts: n/a
Default Re: Did a reset on the OBC & now cart does not move

Quote:
Originally Posted by TahoeDawgZ71 View Post
Kicking on is normal. Kicking off is normal too after it's finished charging. How long does it take to kick off?

what about the diagnostic shut down after a few minutes ?


thank god for spell check

Quote:
Originally Posted by Anselmo View Post
my volt is 49.51 and the charger kicks on and then kicks off, is this normal? Two weeks ago I put new batteries and the charger kicked on and I checked the voltage and it kicked off at about 58 volts.
?????

Last edited by crash test dummy; 09-25-2013 at 07:53 PM.. Reason: ?
  Reply With Quote
Old 09-25-2013, 08:08 PM   #8
TahoeDawgZ71
revolutiongolfcars.com
 
TahoeDawgZ71's Avatar
Club Car
 
Join Date: Mar 2010
Location: Golf Car Capital of The World... Augusta, Georgia
Posts: 10,224
Default Re: Did a reset on the OBC & now cart does not move

Quote:
Originally Posted by crash test dummy View Post

what about the diagnostic shut down after a few minutes ?

There is no diagnostic shutdown after a few minutes on a 1995. That didn't start until the OBC became grey. All the Black and Beige OBC did their calibrating within the first 10 seconds.
TahoeDawgZ71 is offline   Reply With Quote
Old 09-25-2013, 10:30 PM   #9
pete959
Gone Wild
E-Z-GO
 
Join Date: Jun 2013
Location: Atlanta Ga
Posts: 211
Default Re: Did a reset on the OBC & now cart does not move

dawg u r good
pete959 is offline   Reply With Quote
Old 09-25-2013, 10:59 PM   #10
Toolman67
Not Yet Wild
Club Car
 
Join Date: Sep 2013
Posts: 7
Default Re: Did a reset on the OBC & now cart does not move

Hey Dawg I am having the same issue with the charger, it kicks on then within a second or two it kicks off, my issues started when the charger didn't seem to charge the batteries (new charger & batteries, charger has been tested on another club car DS & works fine, batteries have been charged up with a car charger volts up to 48.57), charger still did not want to charge, so was told to do a reset of OBC and now the cart will not move at all, it will move if the charger is plugged in when you press on the pedal, it did move before the reset but just couldn't use the club car charger, let me know what you think... spanish pirates, time for a exorcism, patience is just wearin thin with this cart, thanks
Toolman67 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
How can you reset the OBC if you have "The Cart Key" security keypad? Electric Club Car
Reset without Run/Tow Electric Club Car
do you have to reset the OBC? Electric Club Car
OBC reset Electric Club Car
Why reset the obc ? Electric Club Car


All times are GMT -5. The time now is 01:16 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.9
Copyright ©2000 - 2024, vBulletin Solutions, Inc.
This Website and forum is the property of Buggiesgonewild.com. No material may be taken or duplicated in part or full without prior written consent of the owners of buggiesgonewild.com. © 2006-2017 Buggiesgonewild.com. All rights reserved.