lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 10-31-2013, 09:01 AM   #1
Not Yet Wild
Club Car
 
Join Date: Jul 2013
Location: Asheville, NC
Posts: 7
Default Surging CC

I have a 2000.5 Regen II Cart, 6" lift, 23" tires, DCX 400, upgraded cables, solenoid, diode, and fuse. 1 year old batteries. I love the increased torque and speed, but when I replaced the controller the surging started. It only smooths out at full throttle or sometimes when you find the sweet spot. It is almost impossible to run the cart at low speed. The cart runs smooth as butter in reverse. I checked the linkage and cleaned the Vglide, but the problems seems to be getting worse. Also when I initially push the pedal nothing happens. When I release the pedal and press it down again the cart takes off. Any suggestions? By the way I love this site. All the upgrades to the cart were done from reading the archives. You guys are awesome!
Deercart is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 11-01-2013, 02:28 AM   #2
Gone Wild
Club Car
 
Join Date: Aug 2013
Posts: 266
Default Re: Surging CC

what's going on here? I figure one of you fellas would offer at least a clue and I am curious.
RPatten is offline   Reply With Quote
Unread 11-01-2013, 10:52 AM   #3
Getting Wild
 
Join Date: Jun 2008
Posts: 92
Default Re: Surging CC

I would disconnect the V-glide wiring at the controller and check the resistance while doing a sweep of the throttle.
You would be looking for an irregularity in the readings like it jumping high. Readings should be a smooth transition from apporx 5K pedal released to 0 ohms pedal depressed to the floor.
This is best checked with a scope but most ppl do not have one available.
Depending on how You wired it could be why it feels ok in reverse.
Bill is offline   Reply With Quote
Unread 11-01-2013, 12:18 PM   #4
Not Yet Wild
Club Car
 
Join Date: Jul 2013
Location: Asheville, NC
Posts: 7
Default Re: Surging CC

I will test it, Thanks.
Deercart is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
surging Gas EZGO
Surging Gas EZGO
G22 surging Gas Yamaha
Surging Gas Club Car
Surging Gas EZGO


All times are GMT -5. The time now is 03:25 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.