lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 11-26-2013, 01:06 PM   #11
Gone Wild
 
Join Date: Nov 2013
Posts: 706
Default Re: 09 Precedent throttle problem

just switched out the motor sensor and same result. does anyone have any ideas?
chriskent85 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 11-26-2013, 01:10 PM   #12
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,561
Default Re: 09 Precedent throttle problem

You really should do a load test on the batteries... or just swap them out with the other cart...
Sergio is offline   Reply With Quote
Unread 11-27-2013, 09:07 AM   #13
Gone Wild
 
Join Date: Nov 2013
Posts: 706
Default Re: 09 Precedent throttle problem

So after putting all the electronics from the good cart into the bad cart exept for switching out the motors. After a little tinkering it started working fine. let the cart sit for a few hours and it went back to acting up. i did a load test, at full throttle when it was working the voltage was around 47v
chriskent85 is offline   Reply With Quote
Unread 11-29-2013, 09:17 AM   #14
Gone Wild
 
Join Date: Nov 2013
Posts: 706
Default Re: 09 Precedent throttle problem

So i think i have it narrowed down to the magnet or the speed sensor, after i put the speed sensor from my good cart on the bad cart it started working fine then 2 hours later it stopped, i tapped on the speed sensor and it started working again.
chriskent85 is offline   Reply With Quote
Unread 11-29-2013, 10:02 AM   #15
Gone Wild
 
Sergio's Avatar
Club Car
 
Join Date: Sep 2012
Location: Charlotte, NC
Posts: 4,561
Default Re: 09 Precedent throttle problem

If the sensor or the magnet were broken, the cart would go into limp mode, not stop working as you described.
Unless you tapped hard enough and there is something loose inside the motor itself... not sure what that could be though...
Sergio is offline   Reply With Quote
Unread 11-29-2013, 08:35 PM   #16
Gone Wild
Club Car
 
Join Date: Oct 2008
Location: East Texas
Posts: 318
Default Re: 09 Precedent throttle problem

Load test the batteries and check all the battery cables if you haven't already.
basshawk84 is offline   Reply With Quote
Unread 11-29-2013, 09:44 PM   #17
Gone Wild
 
jjance's Avatar
Club Car
 
Join Date: Feb 2011
Location: Chattanooga TN
Posts: 2,105
Default Re: 09 Precedent throttle problem

Nothing seems to be working so I'd like for you to try this. Check the resistance of the resistor across the solenoid. It should be about 500 ohms.
jjance is offline   Reply With Quote
Unread 11-30-2013, 01:07 PM   #18
Gone Wild
 
Join Date: Nov 2013
Posts: 706
Default Re: 09 Precedent throttle problem

i havent checked that yet but, it i jack the cart up and push the throttle down it will get to speed and then slow down for a sec and speed back up. keeps going up and down for about 20 secs then it will calm down and stay at one speed. after it evens out if i push thje throttle the rest of the way down it shuts off, i keep doing that and after everything warms up i guess it works fine, so i came to the conclusion that after the cart warms up it works fine, any more ideas
chriskent85 is offline   Reply With Quote
Unread 11-30-2013, 01:12 PM   #19
Gone Wild
 
Join Date: Nov 2013
Posts: 706
Default Re: 09 Precedent throttle problem

the only thing i didnt change over is the motor and soleniod so im thinging it has to be one of those.
chriskent85 is offline   Reply With Quote
Unread 12-02-2013, 09:10 AM   #20
Gone Wild
 
Join Date: Nov 2013
Posts: 706
Default Re: 09 Precedent throttle problem

I tried the solenoid and nothing, I guess im gonna switch out motors to see if that fixes the issue. Im lost. Its weird that once the motor gets warmed up it runs fine. I would think if the motor was going out that it would get worse as the motor warms up
chriskent85 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
throttle problem? Electric EZGO
Throttle problem? Electric Club Car
throttle problem Electric EZGO
throttle problem,new controller,throttle works backwards Electric EZGO
Throttle Problem Gas Club Car


All times are GMT -5. The time now is 11:35 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.