|
Electric Club Car Electric DS, and Precedent golf cars |
|
Thread Tools | Display Modes |
05-19-2014, 07:52 PM | #1 |
Gone Wild
Join Date: Mar 2013
Posts: 495
|
97 DS 48 volt solenoid clicks and won't move and charger won't turn on
This club car will click the solenoid and it will move maybe 1 in and that is it. The battery pack showed 47.4 and I checked to see if the solenoid was dropping out and it didn't. Also the charger will not turn on. Charger is fine I put it on my neighbors and charger fired right up. Any ideas what is going on???
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
05-19-2014, 08:37 PM | #2 |
Old Sky Soldier
Join Date: Dec 2011
Location: Kentucky
Posts: 3,881
|
Re: 97 DS 48 volt solenoid clicks and won't move and charger won't turn on
To start with you need to get the batteries charged up then see what you have.
Your batteries are at about 35% charge. You will need to charge them one at a time with an auto charger to get them up to where your charged will kick on. The after that do not run them all the way down before charging. |
05-19-2014, 09:53 PM | #3 |
Gone Wild
Join Date: Mar 2013
Posts: 495
|
Re: 97 DS 48 volt solenoid clicks and won't move and charger won't turn on
How do i charge these 8 volt batteries? I don't have an 8 volt setting on my automotive charger.
|
05-19-2014, 10:04 PM | #4 | |
ΜΟΛΩΝ ΛΑΒΕ
Join Date: Nov 2012
Location: West Virginia
Posts: 4,094
|
Re: 97 DS 48 volt solenoid clicks and won't move and charger won't turn on
Quote:
Maybe someone else has done it another (better or safer) way? |
|
05-19-2014, 11:55 PM | #5 |
Guest
Posts: n/a
|
Re: 97 DS 48 volt solenoid clicks and won't move and charger won't turn on
the only way i've done it is an OBC bypass and watched volts til i got around 49v then undid bypass ,reset OBC, plugged in charger and let it do it's thing
|
05-20-2014, 06:49 AM | #6 |
ΜΟΛΩΝ ΛΑΒΕ
Join Date: Nov 2012
Location: West Virginia
Posts: 4,094
|
Re: 97 DS 48 volt solenoid clicks and won't move and charger won't turn on
Better way ^^^^
|
05-20-2014, 08:32 AM | #7 |
Gone Wild
Join Date: Mar 2013
Posts: 495
|
Re: 97 DS 48 volt solenoid clicks and won't move and charger won't turn on
Sounds good. Jow do i bypass the obc?
|
05-20-2014, 08:43 AM | #8 |
Guest
Posts: n/a
|
Re: 97 DS 48 volt solenoid clicks and won't move and charger won't turn on
to by pass OCB
DO AT YOUR OWN RISK.…do not attempt unless you are familiar with electricity and electronics! There are two ways to force the charger to turn on regardless of the OBC. The first method is to disconnect the cart’s gray wire at the fuse near the charger receptacle. Then using a jumper wire, connect the receptacle side of the fused connector to the cart’s negative battery terminal. This will energize the charger’s 48V relay.then plug charger in |
05-20-2014, 08:48 AM | #9 |
Guest
Posts: n/a
|
Re: 97 DS 48 volt solenoid clicks and won't move and charger won't turn on
while you at it check fuse ...lol
|
05-20-2014, 09:28 AM | #10 |
Gone Wild
Join Date: Mar 2013
Posts: 495
|
Re: 97 DS 48 volt solenoid clicks and won't move and charger won't turn on
Ok i will do it in just a few mins
|
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
'97 Ez GO Txt Solenoid clicks but no move | Electric EZGO | |||
91 ezgo solenoid clicks, wont move | Electric EZGO | |||
my 2000 clubcar ds solenoid clicks when i turn key switch on whats happening? | Electric Club Car | |||
1996 DCS--Solenoid Clicks Won't Move | Electric EZGO | |||
solenoid clicks/ wont move | Electric EZGO |