lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 07-22-2014, 07:34 AM   #1
Not Yet Wild
 
Join Date: Jun 2014
Posts: 20
Default 92 Clicks but wont move - need help

Took my daughter on a ride around the neigborhood. Cart was running just fine. Parked the cart for a second. Got back in and hit the gas and Nothing!

No forward or reverse. Batteries were fully charged.

When you hit the gas in forward, it clicks once but then nothing.

I am no DIY guy, but I would think a wire or something has come loose?? I just put some $$ into it and had a shop put a lift and tires on it. Since then, I have been on a couple 3-4 mile drives and it ran like a top. Now this?

Where do I start?

thanks!
catch2237 is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 07-23-2014, 12:38 PM   #2
Not Yet Wild
 
Join Date: Jun 2014
Posts: 20
Default Re: 92 Clicks but wont move - need help

bumping
catch2237 is offline   Reply With Quote
Unread 07-23-2014, 01:08 PM   #3
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,056
Default Re: 92 Clicks but wont move - need help

check the cables at the F/R switch .. check to ensure contacts are good
check the V-glide make sure wiper is working and making good contact
check resistor assembly .. all coils good and wires not broken
if all that is good motor will need to be tested

here is a diagram of your wiring

crash test dummy is offline   Reply With Quote
Unread 07-23-2014, 01:52 PM   #4
Not Yet Wild
 
Join Date: Jun 2014
Posts: 20
Default Re: 92 Clicks but wont move - need help

thanks Crash Test. Could it be the Solenoid? Some other research on the web and I keep hearing solenoid
catch2237 is offline   Reply With Quote
Unread 07-23-2014, 02:46 PM   #5
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,056
Default Re: 92 Clicks but wont move - need help

Quote:
Originally Posted by catch2237 View Post
thanks Crash Test. Could it be the Solenoid? Some other research on the web and I keep hearing solenoid
yes and no
usually if you hear the click the solenoid is good
there are times it's bad

test solenoid
Quote:
Disconnect the negative battery cable from the battery. remove all wires, restorer , and diode from solenoid
test 1
Connect an volt meter, set on continuity, place on the two large terminal studs. The meter should indicate no continuity, Replace the solenoid if continuity is present.
test 2
Using jumper wires attach from main positive and main negative of battery pack to the two small solenoid studs, polarity is not important. You should hear a click as the solenoid engages, and the meter should indicate continuity on the two large terminals. Replace the solenoid if continuity is not present.
if solenoid clicks rapidly solenoid is bad
crash test dummy is offline   Reply With Quote
Unread 07-23-2014, 04:08 PM   #6
DS Drivers Club Founder
 
CCFanatic's Avatar
Club Car
 
Join Date: Jul 2013
Location: Upstate NY
Posts: 3,409
Default Re: 92 Clicks but wont move - need help

Quote:
Originally Posted by catch2237 View Post
92 Clicks but wont move - need help
Yeah, I'd say you have an issue there
CCFanatic is offline   Reply With Quote
Unread 08-04-2014, 11:10 AM   #7
Not Yet Wild
 
Join Date: Jun 2014
Posts: 20
Default Re: 92 Clicks but wont move - need help

Just an update - it was the solenoid. I ordered a new one and put it in........hit the gas and she runs good!

I was relieved for sure!
catch2237 is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Ezgo dcs solenoid clicks but wont disengage and wont move Electric EZGO
need help! dcs clicks but wont move Electric EZGO
EZGO just clicks wont move Electric EZGO
92 club car clicks but wont move Electric Club Car
95Carryall just clicks,wont move Electric Club Car


All times are GMT -5. The time now is 01:46 PM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.