lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 07-28-2014, 10:43 PM   #1
Not Yet Wild
 
RJMarks's Avatar
Club Car
 
Join Date: Jul 2014
Location: NW FL
Posts: 6
Default Which Is the keyed power wire on Clubman DS

I have a 92 electric Clubman. Hooking up 36v to 12 v converter. I need to know which wire is the keyed power. I thought it was the green one but after searching this site I read where it was the blue one. Now I'm confused.
RJMarks is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 07-29-2014, 02:47 PM   #2
Not Yet Wild
 
RJMarks's Avatar
Club Car
 
Join Date: Jul 2014
Location: NW FL
Posts: 6
Default Re: Which Is the keyed power wire on Clubman DS

C'mon .. I know I'm new to this and I'm sure if I hook up a voltmeter with neg on the negative end terminal of the battery pack and the positive to one of the lines, eventually I will figure it out. But I am attempting to do this all myself and it gets construed and time consuming while hooking up the volt meter and turning the key and reading the meter. I was hoping the collective genius of this group would espouse upon me their knowledge. Feel free to preface it with, "Whatta are you stupid?". I just want to do it right and not blow up anything. On my wife's cart :)
RJMarks is offline   Reply With Quote
Unread 07-29-2014, 02:54 PM   #3
Gone Wild
 
mymonstertruck's Avatar
Club Car
 
Join Date: Aug 2013
Location: Michigan
Posts: 508
Default Re: Which Is the keyed power wire on Clubman DS

Key word wife's cart lol. I wish I had an answer but I have a precedent.
mymonstertruck is offline   Reply With Quote
Unread 07-29-2014, 03:54 PM   #4
Old Sky Soldier
 
mrgolf's Avatar
Club Car
 
Join Date: Dec 2011
Location: Kentucky
Posts: 2,975
Default Re: Which Is the keyed power wire on Clubman DS

What kind of reducer? Can you post photo?
mrgolf is online now   Reply With Quote
Unread 07-29-2014, 04:17 PM   #5
Not Yet Wild
 
RJMarks's Avatar
Club Car
 
Join Date: Jul 2014
Location: NW FL
Posts: 6
Default Re: Which Is the keyed power wire on Clubman DS

its a Madjax 48/36 v to 12 v reducer. Green wire from reducer is to go to switched power. I don't know where to plug that to. Also the negative power from battery ... do I simply hook it to the negative on the last battery? Does it matter?
Attached Images
File Type: jpg Madjax reducer.jpg (3.0 KB, 0 views)
RJMarks is offline   Reply With Quote
Unread 07-29-2014, 06:56 PM   #6
Old Sky Soldier
 
mrgolf's Avatar
Club Car
 
Join Date: Dec 2011
Location: Kentucky
Posts: 2,975
Default Re: Which Is the keyed power wire on Clubman DS

Connect the neg to the main neg on your battery, you will need to pull the dash and check your key switch with a volt meter. There should be one connection with no voltage until you turn the key on. That is where you want to connect the switch wire. Be sure to put cart in tow before working on batteries if cart has a tow run switch. Disconnect the batteries before pulling dash. After you get the dash pulled out you can connect the batteries back up to do the voltage test. Then disconnect the batteries to hook your wires. Then re hook cables to test, if everything works ok disconnect again to re install dash. Also run tow needs to be onto do test. See clear as mud.
mrgolf is online now   Reply With Quote
Unread 07-29-2014, 07:32 PM   #7
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,021
Default Re: Which Is the keyed power wire on Clubman DS

Quote:
Originally Posted by RJMarks View Post
its a Madjax 48/36 v to 12 v reducer. Green wire from reducer is to go to switched power. I don't know where to plug that to. Also the negative power from battery ... do I simply hook it to the negative on the last battery? Does it matter?
blue wire is switched ... you can splice in at the f/r assembly before the f/r limit switch

neg goes to #6 battery in pack ... yes it matters !!




Quote:
Originally Posted by mrgolf View Post
. Be sure to put cart in tow before working on batteries if cart has a tow run switch.:
92 has no run/tow switch
crash test dummy is online now   Reply With Quote
Unread 07-29-2014, 08:33 PM   #8
Not Yet Wild
 
RJMarks's Avatar
Club Car
 
Join Date: Jul 2014
Location: NW FL
Posts: 6
Default Re: Which Is the keyed power wire on Clubman DS

Thanks all! It IS the blue wire! Appreciate the help all!!!!
RJMarks is offline   Reply With Quote
Unread 07-29-2014, 08:40 PM   #9
Old Sky Soldier
 
mrgolf's Avatar
Club Car
 
Join Date: Dec 2011
Location: Kentucky
Posts: 2,975
Default Re: Which Is the keyed power wire on Clubman DS

CTD, What took you so long. You picture is worth more than all my words.
mrgolf is online now   Reply With Quote
Unread 07-29-2014, 08:47 PM   #10
Dazed & Confused
 
crash test dummy's Avatar
Club Car
 
Join Date: Nov 2011
Location: Z-HELLS FL
Posts: 14,021
Default Re: Which Is the keyed power wire on Clubman DS

i was vacuuming
crash test dummy is online now   Reply With Quote
Reply

Tags
converter, keyed, wiring
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
Keyed power source Gas Club Car
power wire Electric EZGO
Want to trade Clubman seat for EZGO seat Golf Carts and Parts
Reconecting red power wire to batterys Electric Club Car
Break light - no power red wire Electric Club Car


All times are GMT -5. The time now is 11:08 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.