lifted club cars - lifted ezgo
Home FAQDonate Who's Online
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car
Electric Club Car Electric DS, and Precedent golf cars



Post New Thread  Reply
Thread Tools Display Modes
Unread 08-09-2014, 07:33 PM   #1
Not Yet Wild
 
Join Date: Aug 2014
Posts: 1
Default Electric Golf Cart "Jumpy" Start

Hey Guys!

I am new to the forum! I have seen some great responses. I have a Club Car (AA0233-180500)

Today I charged my batteries and jumped in for a ride. When backing out the the shop, it did fine. Put in forward, did fine. Went around the block full speed no problems. Came to a stop sign and began to accelerate and the cart "bucked" and "jumped." Once it reached about half of the full speed it leveled out and ran smooth, it is just while accelerating. I suspect that it could possiblY be the solenoid or the batteries. I check all the connection and tightened them.

I have an EMP 2 speed motor, it runs great...When the cart isnt "bucking."

Any suggestions to solve my problem would be great!

Thanks
matthew.lee is offline   Reply With Quote
Alt Today
BGW

Golf car forum Sponsored Links

__________________
This advertising will not be shown in this way to registered members.
Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum
   
Unread 08-09-2014, 07:50 PM   #2
Gone Wild
 
teecro's Avatar
Club Car
 
Join Date: Jun 2014
Location: Sunset Bay, TN
Posts: 2,214
Default Re: Electric Golf Cart "Jumpy" Start

sorry read wrong; eyes tired...
teecro is offline   Reply With Quote
Unread 08-22-2014, 01:22 PM   #3
Not Yet Wild
 
Join Date: Nov 2010
Posts: 5
Default Re: Electric Golf Cart "Jumpy" Start

Mine has started bucking a bit after replacing controller and I have been told by the company that sold me the controller that it's the Club Car throttle . It's an electric unit under the floor board that attaches to or near the throttle cable .
I have been traveling so have not tried to fix yet. The unit casts around $130.
jakegolf is offline   Reply With Quote
Unread 08-22-2014, 03:50 PM   #4
Getting Wild
 
Join Date: Feb 2008
Posts: 75
Default Re: Electric Golf Cart "Jumpy" Start

2000 cc should have a vglide for potentiometer. Mcors started in 2001.

Black pie shaped box beside batteries Inside is a wiper arm with a brush that moves across contacts. If you have a speed controller it will have two small wires coming out , yellow and green. You can check the ohm reading on these two wires should be 5000 - 0 ohms, 5000 pedal up 0 pedal pressed all the way down. Sometimes the contacts or brush gets warn and makes the cart jerk. On the bottom of the vglide each contact is linked to the next with resistors make sure none are broken or loose.

The factory controllers will work with almost any range of 5000 down ohms, for example 7300 ohms to 2300 ohms. Alltrax controllers will not, the controller looks for a specific 5000 - 0 ohm range give or take few 100 ohms.
Carts Zone is offline   Reply With Quote
Unread 08-22-2014, 04:12 PM   #5
Not Yet Wild
 
Join Date: Nov 2010
Posts: 5
Default Re: Electric Golf Cart "Jumpy" Start

Thanks.I had just installed an Altrax controller when the jerkiness started. Mine is just in reverse. Also mine does not seem like it is a fast as it was with the stock controller (I have a D&D 6002 motor).
Since you seem to be knowledgeable, my carts low voltage light is now on when charging and while driving after being fully charged. (My batteries are new Trojans )
jakegolf is offline   Reply With Quote
Unread 08-22-2014, 04:23 PM   #6
Getting Wild
 
Join Date: Feb 2008
Posts: 75
Default Re: Electric Golf Cart "Jumpy" Start

read this post Battery Warning light on 2007 Precedent

you can also try resetting the obc
Carts Zone is offline   Reply With Quote
Unread 08-22-2014, 04:30 PM   #7
Not Yet Wild
 
Join Date: Nov 2010
Posts: 5
Default Re: Electric Golf Cart "Jumpy" Start

2002 Club Car IQ. Altrax controller has the speed wires coming out of the motor not used .
jakegolf is offline   Reply With Quote
Reply
Go Back   Buggies Gone Wild Golf Cart Forum > Golf Cart Repair and Troubleshooting > Electric Club Car


Thread Tools
Display Modes


Similar Threads
Thread Forum
how do i get rid of annoying "jumpy" low end Gas EZGO
Cart "jerks hard" on start Gas Club Car
Very "Jumpy" after Torque & Speed Upgrades Extreme DC!
Found another cl ad "Marathon Electric Golf Cart - $500 (North Augusta)" Electric EZGO
Electric Golf Cart "running out of gas" Electric golf carts


All times are GMT -5. The time now is 07:49 AM.


Club Car Electric | EZGO Electric | Lifted Golf Carts | Gas EZGO | Used Golf Carts and Parts

Powered by vBulletin® Version 3.8.6
Copyright ©2000 - 2017, Jelsoft Enterprises Ltd.
Content Relevant URLs by vBSEO ©2011, Crawlability, Inc.