|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-02-2016, 10:44 AM | #1 |
Not Yet Wild
Join Date: Aug 2016
Posts: 1
|
Cart Acting Dead But Batteries Are Fine
Hi all,
I've been searching high and low and can't find a solid answer to my issue. Have a 2007 EZ Go TXT PDS 36v. Replaced the batteries a few months ago (Battery Source batteries). Replaced the solenoid about two years ago. The cart has been acting sluggish and then dying right out of the drive way sometimes; sometimes I get a mile out of it before it trips the 2/1 Beep Code (low voltage). I push it (or tow it) back to the house, put a volt meter on the battery pack and the pack reads about 38-40 volts each time and each battery is sitting around 6.2-6.5. Also, my state of charge meter is reading completely full even though the cart beeps for low voltage and then dies. All I can figure is that one of the cables in the pack might be going bad and causing a break in the circuit - but the cables are nice and tight and the terminals are completely clean. I figure if it's a solenoid issue it should be a "zero or one" - meaning the cart goes or it doesn't (if the solenoid doesn't engage). Does that check? Controller issue? I put it in diagnostic mode and it doesn't tell me anything. Thoughts? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-02-2016, 10:49 AM | #2 |
Gone Wild
Join Date: Jun 2010
Location: Central Florida
Posts: 2,757
|
Re: Cart Acting Dead But Batteries Are Fine
If it was a solenoid issue, then the cart would give a code for solenoid dropout, not low voltage. Is there a way you can alligator clip your test leads to the main positive and negative and go for a ride? If so, watch the voltage as much as possible. It sounds like one of the batteries is dropping out under load. Even new batteries can fail.
|
08-02-2016, 10:57 AM | #3 |
Just Gone
Join Date: Sep 2015
Location: North Carolina
Posts: 3,549
|
Re: Cart Acting Dead But Batteries Are Fine
Crazy question, but were the batteries you replaced golf cart type deep cycle batteries?
|
08-02-2016, 01:02 PM | #4 |
Gone Wild
Join Date: May 2012
Location: Rio Verde, Az
Posts: 7,170
|
Re: Cart Acting Dead But Batteries Are Fine
Connect your DVM and see what the pack voltage is when you try to go and it dies.
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Put new batteries and cart is dead | Electric Club Car | |||
Acting like batteries are not charging.....sometimes | Electric EZGO | |||
Replaced batteries, now cart is dead. | Electric EZGO | |||
Dead Batteries/Cart will not go | Electric Club Car | |||
Batteries test fine, cart will not charge | Electric EZGO |