|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
08-27-2016, 07:36 PM | #1 |
Not Yet Wild
Join Date: Aug 2016
Posts: 28
|
1999 EZGO/2005 Western dead
I have a 2005 western but I'm posting it here because it's basically a 1999 EZGO PDS Cart.
Pulled it off the charger today it ran about 100 feet and then died, I was able to get it home barely, but I had to do it in reverse and it barely made it. The batteries are old but they still read 49volts across all seven, that's right it's a 42volt system. It has an on board charger and I have been noticing the strong rotten egg smell while charging lately. Any help would be greatly appreciated. |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
08-28-2016, 09:53 AM | #2 |
Not Yet Wild
Join Date: Aug 2016
Posts: 28
|
Re: 1999 EZGO/2005 Western dead
Anyone, Bueller, Bueller, Bueller?
|
08-28-2016, 12:32 PM | #3 |
Gone Wild
Join Date: May 2012
Location: Rio Verde, Az
Posts: 7,171
|
Re: 1999 EZGO/2005 Western dead
Sounds like it's time for new batteries. Check water level and check voltage under load.
|
09-13-2016, 08:17 PM | #4 |
Not Yet Wild
Join Date: Aug 2016
Posts: 28
|
Re: 1999 EZGO/2005 Western dead
Finally got around too checking voltage under load, yup these things are shot. Going this weekend to get new Trojans, taking her up to 48 volts with a new controller.
|
09-15-2016, 09:34 AM | #5 |
Gone Wild
Join Date: Feb 2012
Location: Indio, CA The Desert!
Posts: 1,263
|
Re: 1999 EZGO/2005 Western dead
Don't forget to get a 48 volt charger also.
|
09-16-2016, 04:02 PM | #6 |
Not Yet Wild
Join Date: Aug 2016
Posts: 28
|
Re: 1999 EZGO/2005 Western dead
I've got an on board charger, Delta-Q, I have to figure out how to change the Algorythm , I played hookie from work today, picked up the batteries and new wires, got them installed and its jerky, and it stutters before it takes off I was planning on changing out the controller to an Alltrax, but I thought the cart would work fine until I got around to it. What is this stutter thing it's doing? Is it something else other than the controller? Anyone know how to change the Algorythm on a Delta-Q?
|
09-16-2016, 04:50 PM | #7 |
Gone Wild
Join Date: Feb 2012
Location: Indio, CA The Desert!
Posts: 1,263
|
Re: 1999 EZGO/2005 Western dead
You can google how to change the algorithum, its pretty simple. i think you need to disconnect the charger wires, then hold the wire ( red i think ) on the positive post for a few seconds, and the flashes tell you what it is set for now, Then you tap the the wire to the terminal until you get the number of flashes you need.
But you are aware, you are only changing the charge algorithum to match a certain brand of battery? You will still have a 42 volt charger. |
09-16-2016, 06:41 PM | #8 |
Not Yet Wild
Join Date: Aug 2016
Posts: 28
|
Re: 1999 EZGO/2005 Western dead
I was under the impression the Delta Q was universal?
|
09-16-2016, 07:26 PM | #9 |
Not Yet Wild
Join Date: Aug 2016
Posts: 28
|
Re: 1999 EZGO/2005 Western dead
|
09-16-2016, 07:29 PM | #10 |
Gone Wild
Join Date: Feb 2012
Location: Indio, CA The Desert!
Posts: 1,263
|
Re: 1999 EZGO/2005 Western dead
If the batteries are good, and the proper voltage, and charged up, and is stuttering, might check the ITS in the floor?
|
|
|
Similar Threads | ||||
Thread | Forum | |||
2005 western on ezgo chassis intermittent | Electric EZGO | |||
1999 G16E is Dead | Electric Yamaha | |||
2005 ezgo/ western value | Electric EZGO | |||
Completley dead 1999 ezgo | Electric EZGO | |||
1999 DCS Controller Dead??? | Electric EZGO |