|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
09-17-2016, 09:34 PM | #1 |
Gone Wild
Join Date: Apr 2016
Location: North Texas
Posts: 150
|
2010 RXV charging issues
I'm getting a single red blink on my quiq charger. From what I've read the troubleshooting steps are as follows:
"Fault: poor contact in the DC connector or dirty contacts or Battery Temperature Fault: battery temperature is greater than 122° F (50° C) or less than 14° F (-10° C)." I've undone all battery connections and clean them with a brush and then baking soda & water. No change. Its done this before and I cleaned the battery connections. I've only been using the cart on a regular basis for a month. Cart currently runs fine. Any suggestions on where to go from here? |
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
09-17-2016, 10:04 PM | #2 |
Gone Wild
Join Date: May 2015
Location: Central Florida
Posts: 2,114
|
Re: 2010 RXV charging issues
The Charger is a pile of junk if its the black or silver one. But the red light should blink a code between 1-6. Need that code
|
09-17-2016, 10:16 PM | #3 |
Gone Wild
Join Date: Apr 2016
Location: North Texas
Posts: 150
|
Re: 2010 RXV charging issues
Its yellow and black.
|
09-17-2016, 10:36 PM | #4 |
Not Yet Wild
Join Date: Sep 2013
Posts: 56
|
Re: 2010 RXV charging issues
|
09-18-2016, 06:28 AM | #5 | |
Gone Wild
Join Date: Jun 2014
Location: Sunset Bay, TN
Posts: 2,390
|
Re: 2010 RXV charging issues
Quote:
Whoops likely a redundant post... I see now that this is a hard wired charger... |
|
09-18-2016, 06:40 AM | #6 |
Gone Wild
Join Date: May 2015
Location: Central Florida
Posts: 2,114
|
Re: 2010 RXV charging issues
|
09-18-2016, 10:11 AM | #7 |
Gone Wild
Join Date: Apr 2016
Location: North Texas
Posts: 150
|
Re: 2010 RXV charging issues
1 red blink
|
09-18-2016, 10:43 AM | #8 |
Gone Wild
Join Date: Jul 2010
Location: Peachtree City, Ga.
Posts: 2,759
|
Re: 2010 RXV charging issues
What is the voltage per cell? (Pack voltage divided by number of cells)
This was working before and just started giving the fault suddenly? is there a battery life saver or something similar connected to the batteries? |
09-18-2016, 10:53 AM | #9 |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: 2010 RXV charging issues
This may not apply, but you charger looks the same as mine.
LED operation codes are; Short Green Flash = Less than 80% charged Long Green Flash = More than 80% charged Steady Green = 100% charged Red Flash: Light turns on briefly, but does not flash after that - check for valid AC voltage at the charge cord. One Red Flash: One flash, a pause and then another flash and a pause - Battery Temperature Fault: Battery temperature is out of range. Greater than 122F or less than 14F Two Red Flashes: Two flashes, a pause and then another two flashes and a pause - Battery Voltage Fault: Battery pack is greater than 67.2 volts or less than 36.0 volts. Three Red Flashes: Three flashes, a pause and then another three flashes and a pause - Battery Charge Time-out: Charge Time Exceeded. This indicates a problem with the battery pack, or the charger output current was severely reduced due to high ambient temperatures. Four Red Flashes: Four flashes, a pause and then another four flashes and a pause - Battery Fault: Charge time exceeded (16 hours) with battery voltage still below nominal voltage. This indicates an issue with the battery pack not charging within the maximum time allowed. Five Red Flashes: Five flashes, a pause and then another five flashes and a pause - Internal Overtemperature Shutdown of the charger. Six Red Flashes: Six flashes, a pause and then another six flashes and a pause - Charger Fault: If this fault repeats after unplugging and replugging the charger, the charger needs service or repair. Bob |
09-18-2016, 10:56 AM | #10 |
Gone Wild
Join Date: Apr 2016
Location: North Texas
Posts: 150
|
Re: 2010 RXV charging issues
I'll check voltage.
The issue comes up occasionally. The last time I cleaned all the battery connections and it worked again. No battery saver etc Last edited by sltintexas; 09-18-2016 at 10:58 AM.. Reason: Added info |
|
Thread Tools | |
Display Modes | |
|
Similar Threads | ||||
Thread | Forum | |||
2010 EZGO RXV Charging Issues | Electric EZGO | |||
2010 club car acceleration issues | Electric Club Car | |||
2010 Tomberlin Emerge Possible Battery Issues | Electric golf carts | |||
2010 RXV Start stop issues | Gas EZGO | |||
Speed Magnet Issues with 2010 CC Precedent i2 Excel | Electric Club Car |