|
Electric EZGO Electric EZ GO Marathon, Medalist, TXT and RXV. |
|
Thread Tools | Display Modes |
10-12-2016, 12:19 AM | #1 |
Not Yet Wild
Join Date: Oct 2016
Posts: 4
|
Rxv will not move, beep, or unlock brake.
2009 rxv cart. Turn key and nothing happens. I have change key switch, it has 48 volts on blue wire coming from charging port, has new motor brake. selonoid not pulling in ( will pull in if I jump a ground from battery bank to - side of selonoid. Cart will not move in tow either. Brake will unlock if I follow instruction under the controller cover and my be the plugs around.
|
Today | |
Sponsored Links
__________________
This advertising will not be shown in this way to registered members. Register your free account today and become a member on Buggies Gone Wild Golf Cart Forum |
|
10-12-2016, 02:33 AM | #2 |
Gone Wild
Join Date: Apr 2016
Location: North Texas
Posts: 150
|
Re: Rxv will not move, beep, or unlock brake.
Have you measured the voltage of the battery pack? I had similar experience when mine sat and batteries drained. RXV will shutdown once batteries get to a certain point.
|
10-12-2016, 10:48 AM | #3 |
Not Yet Wild
Join Date: Oct 2016
Posts: 4
|
Re: Rxv will not move, beep, or unlock brake.
Yes I have load tested the batteries also, voltage at battery pack is 53.8. All terminals are clean. The cart was running fine and just quit and will not do anything.
|
10-12-2016, 05:23 PM | #4 |
Getting Wild
Join Date: Oct 2007
Location: Charleston, SC
Posts: 106
|
Re: Rxv will not move, beep, or unlock brake.
Its a long shot but there is a connector under the cup holder that must be plugged in. If it has worker loose cart wont move. Just a thought. Good luck and let us know what you find.
|
10-12-2016, 07:26 PM | #5 |
Not Yet Wild
Join Date: Oct 2016
Posts: 4
|
Re: Rxv will not move, beep, or unlock brake.
Yes sir, I check that also, made sure on the back side of the plug with an ohm meter.
|
10-12-2016, 10:17 PM | #6 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Rxv will not move, beep, or unlock brake.
Search the site for Rxv Danaher troubleshooting Guide. It has many tests & specs for you to test. Sounds like possible "DC bus low" from failed Resistor control module. Usually that failure will still allow brake unlock, but I have seen that code/failure do many strange things. Don't spend another dollar on parts until you get the guide & start checking every spec in there. (also, stop "jumping" the solenoid, you could kill your controller by jumping circuits that are managed by the controller). The Rxv has sensitive electronics, it ain't like an old "resistor car" that barely cares what you do to it.
|
10-17-2016, 08:58 PM | #7 |
Not Yet Wild
Join Date: Oct 2016
Posts: 4
|
Re: Rxv will not move, beep, or unlock brake.
I was able to get a controller from a working cart, I now can hear the solenoid pull in, the cart will check the motor brake, the buzzer sounds, but still will not move. The closest cart shop that has a programmer is about 160 miles away...I have check both brake and throttle switches per the specs on the troubleshooting guide. The brake will now unlock in tow mode. Anything else I should check?
|
10-18-2016, 12:29 AM | #8 |
Over This Interview Is...
Join Date: Jun 2012
Location: AZ
Posts: 17,449
|
Re: Rxv will not move, beep, or unlock brake.
There's about 50 tests you could try in the guide. It's a "shotgun approach" without the codes given by the programmer.
|
10-18-2016, 07:15 AM | #9 | |
Gone Insane
Join Date: Oct 2015
Location: TN/NC/GA Tri-state area
Posts: 3,952
|
Re: Rxv will not move, beep, or unlock brake.
Quote:
Bob |
|
06-27-2020, 05:38 PM | #10 |
Not Yet Wild
Join Date: Jun 2020
Posts: 3
|
Re: Rxv will not move, beep, or unlock brake.
I have the 2009 cart as well and mine has sat...however even after replacing the batteries I don’t have a buzzing and it won’t switch into tow mode or move! Lights and horn all work
|
|
|
Similar Threads | ||||
Thread | Forum | |||
Reverse Beep Always present- Cart will not move F or R | Electric EZGO | |||
2010 ezgo rxv no click from solenoid no reverse beep doesn't move | Electric EZGO | |||
36V EZ-GO - Cart won't move, but will beep when in Rev | Electric EZGO | |||
Reverse beep-beep-beep delete? | Electric EZGO | |||
Unlock Club car 1989 | Gas EZGO |